Heater And A/C Unit Overview (Manual A/C System)
WARNING: This page is about a different car, the 2016 Volkswagen Beetle, 2015 Volkswagen Beetle, 2014 Volkswagen Beetle, 2013 Volkswagen Beetle, and 2012 Volkswagen Beetle. However, it is still accessible from the selected car via links, so may be relevant.
- Junction Box
- Recirculation Door Motor -V113-
- Removing and Installing. Refer to Air Recirculation Door Motor -V113- WITH Recirculation Door Motor Position Sensor -G143- .
- Seal
- Air Intake Housing
- Air Recirculation Door
- Bracket
- Evaporator Housing Upper Section
- Evaporator housing assembly overview. Refer to EVAPORATOR HOUSING OVERVIEW .
- Evaporator Housing Lower Section
- Evaporator housing assembly overview. Refer to EVAPORATOR HOUSING OVERVIEW .
- Fresh Air Blower Series Resistor with Fuse -N24-
- Removing and Installing. Refer to Fresh Air Blower Series Resistor with Fuse -N24- .
- Fresh Air Blower -V2-
- Checking: Vehicle Diagnostic Tester
- Removing and Installing. Refer to Fresh Air Blower -V2- .
- Dust and Pollen Filter
- With activated charcoal insert
- Dust and pollen filter general information. Refer to DUST AND POLLEN FILTER .
- Removing and Installing. Refer to DUST AND POLLEN FILTER .
- Front Passenger Side Footwell Trim Panel
- Wiring Harness for Heater and Air Conditioner
- Condensation Water Drain
- Removing and installing, checking CONDENSATION WATER DRAIN
- Evaporator Temperature Sensor -G308-
- Removing and Installing. Refer to Evaporator Temperature Sensor -G308- .
- Auxiliary Heater Heating Element -Z35-
- Only installed on vehicles with Diesel engine without auxiliary water heater
- Removing and installing. Refer to Auxiliary Heater Heating Element -Z35- .
- Switch-on criteria. Refer to Installing .
- Switch-off criteria. Refer to Installing .
- Heater Core
- Removing and installing. Refer to HEATER CORE .
- After replacing heater core, replace all the coolant. Refer to COOLANT, DRAINING AND FILLING (CJAA, CVCA) , COOLANT, DRAINING AND FILLING (CPLA, CPPA, CPKA, CPRA) or COOLANT, DRAINING AND FILLING (CBTA, CBUA) . .
- Evaporator
- Removing and Installing. Refer to EVAPORATOR .
- Expansion Valve
- Removing and Installing. Refer to EXPANSION VALVE .
- Threaded Plate
- To attach the refrigerant lines to the evaporator