LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2020 >> Prius XLE >> Repair and Diagnosis >> External Pages >> Different car >> Section 22 (Audio / Video System - Service Information) >> Radio Receiver >> Removal [04/2018 -] >> Procedure

Removal [04/2018 -]: Procedure

WARNING: This page is about a different car, the 2022 Toyota Avalon, 2021 Toyota Avalon, 2020 Toyota Avalon, and 2019 Toyota Avalon. However, it is still accessible from the selected car via links, so may be relevant.
  1. PRECAUTION 
    1. w/o Navigation System:
      NOTE:
      • When replacing the radio and display receiver assembly, always replace it with a new one. If a radio and display receiver assembly which was installed to another vehicle is used, the following may occur:
        • A communication malfunction DTC may be stored.
        • The radio and display receiver assembly may not operate normally.

      for Gasoline Model: Refer to PRECAUTION [04/2018 - 08/2021] , or refer to PRECAUTION [08/2021 -]

      for HV Model: Refer to PRECAUTION [04/2018 - 08/2021] , or refer to PRECAUTION [08/2021 -]

    2. w/ Navigation System:
      NOTE:
      • When replacing the radio and display receiver assembly or navigation ECU, always replace it with a new one. If a radio and display receiver assembly or navigation ECU which was installed to another vehicle is used, the following may occur:
        • A communication malfunction DTC may be stored.
        • The radio and display receiver assembly or navigation ECU may not operate normally.
      • After replacing the radio and display receiver assembly, if "New software is not compatible with the system. Contact your dealer." is displayed on the multi-display, update the software of the navigation ECU.

      for Gasoline Model: Refer to PRECAUTION [04/2018 - 08/2021] , or refer to PRECAUTION [08/2021 -]

      for HV Model: Refer to PRECAUTION [04/2018 - 08/2021] , or refer to PRECAUTION [08/2021 -]

  2. REMOVE LOWER INSTRUMENT PANEL FINISH PANEL LH 

    Refer to PROCEDURE - Step 3 [04/2018 - 08/2020] , or refer to PROCEDURE - Step 3 [08/2020 -]

  3. REMOVE LOWER INSTRUMENT PANEL FINISH PANEL RH 

    Refer to PROCEDURE - Step 4 [04/2018 - 08/2020] , or refer to PROCEDURE - Step 4 [08/2020 -]

  4. REMOVE FRONT CONSOLE UPPER PANEL GARNISH 

    Refer to PROCEDURE - Step 5 [04/2018 - 08/2020] , or refer to PROCEDURE - Step 5 [08/2020 -]

  5. REMOVE CONSOLE BOX POCKET SUB-ASSEMBLY 

    Refer to PROCEDURE - Step 6 [04/2018 - 08/2020] , or refer to PROCEDURE - Step 6 [08/2020 -]

  6. REMOVE CENTER INSTRUMENT CLUSTER FINISH PANEL SUB-ASSEMBLY 

    Refer to PROCEDURE - Step 7 [04/2018 - 08/2020] , or refer to PROCEDURE - Step 7 [08/2020 -]

  7. REMOVE CENTER NO. 1 INSTRUMENT CLUSTER FINISH PANEL 

    Refer to PROCEDURE - Step 13 [04/2018 - 08/2021] , or refer to PROCEDURE - Step 13 [08/2021 -]

  8. REMOVE CENTER NO. 2 INSTRUMENT CLUSTER FINISH PANEL 

    Refer to PROCEDURE - Step 14 [04/2018 - 08/2021] , or refer to PROCEDURE - Step 14 [08/2021 -]

  9. REMOVE RADIO AND DISPLAY RECEIVER ASSEMBLY WITH BRACKET 
    1. Remove the 4 bolts.
      GTY925057Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    2. Pull the radio and display receiver assembly with bracket toward the rear of the vehicle to disengage the 5 clips.
      GTY931007Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      Remove in this Direction
    3. Disconnect each connector and remove the radio and display receiver assembly with bracket.
  10. REMOVE INTERIOR ILLUMINATION LIGHT SUB-ASSEMBLY 

    Refer to PROCEDURE - Step 2

  11. REMOVE NO. 1 RADIO RECEIVER BRACKET 
    1. Remove the 4 screws and No. 1 radio receiver bracket.
      GTY925054Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  12. REMOVE NO. 2 RADIO RECEIVER BRACKET 
    1. Remove the 4 screws and No. 2 radio receiver bracket.
      GTY925053Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  13. REMOVE NO. 2 INSTRUMENT PANEL REGISTER ASSEMBLY 
    1. Disengage the 8 claws and remove the No. 2 instrument panel register assembly as shown in the illustration.
      GTY878361Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      Remove in this Direction
  14. REMOVE RADIO AND DISPLAY RECEIVER ASSEMBLY 
scientia non olet · About LEMON Manuals