LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2015 >> Avalon Hybrid Limited >> Repair and Diagnosis >> Brakes >> Parking Brake System >> Parking Brake (Service Information) (Hybrid) >> Parking Brake Assembly >> Disassembly [10/2014 - ] >> Procedure

Disassembly [10/2014 - ]: Procedure

  1. PRECAUTION 
    NOTE:

    After turning the power switch off, waiting time may be required before disconnecting the cable from the negative (-) auxiliary battery terminal, Therefore, make sure to read the disconnecting the cable from the negative (-) auxiliary battery terminal notice before proceeding with work (Refer to PRECAUTION [10/2014 - ] ).

  2. DISABLE BRAKE CONTROL 

    Refer to PROCEDURE - Step 2

  3. REMOVE REAR WHEEL 
  4. SEPARATE REAR DISC BRAKE CALIPER ASSEMBLY 

    Refer to PROCEDURE - Step 4

  5. REMOVE PARKING BRAKE SHOE ADJUSTING HOLE PLUG 
  6. REMOVE REAR DISC 

    Refer to PROCEDURE - Step 16

  7. REMOVE PARKING BRAKE SHOE RETURN TENSION SPRING (for Front Side) 
    1. Remove the parking brake shoe return tension spring.
      GTY322425Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  8. REMOVE PARKING BRAKE SHOE RETURN TENSION SPRING (for Rear Side) 
    1. Remove the parking brake shoe return tension spring.
      GTY317235Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  9. REMOVE PARKING BRAKE SHOE HOLD DOWN COMPRESSION SPRING (for Front Side) 
    1. Using SST, remove the parking brake shoe hold down compression spring.
      GTY547600Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      • SST: 09718-00011 
  10. REMOVE PARKING BRAKE SHOE STRUT 
    1. Pull the No. 1 parking brake shoe assembly towards the front of the vehicle by hand as shown in the illustration.
      GTY317233Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    2. Remove the parking brake shoe strut.
      GTY317234Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  11. REMOVE PARKING BRAKE SHOE HOLD DOWN COMPRESSION SPRING (for Rear Side) 
    1. Using SST, remove the parking brake shoe hold down compression spring.
      GTY591918Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      • SST: 09718-00011 
  12. SEPARATE PARKING BRAKE SHOE LEVER 
    1. Expand the No. 1 and No. 2 parking brake shoe assemblies outward by hand and pull downward to separate them from the parking brake plate.
      GTY317229Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    2. Separate the parking brake shoe lever from the No. 2 parking brake shoe assembly.
  13. REMOVE PARKING BRAKE SHOE ADJUSTING SCREW SET 
    1. Remove the parking brake shoe adjusting screw set.
      GTY317231Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  14. REMOVE NO. 1 PARKING BRAKE SHOE ASSEMBLY 
    1. Remove the No. 1 parking brake shoe assembly.
      GTY317232Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  15. REMOVE PARKING BRAKE SHOE RETURN TENSION SPRING (for Lower Side) 
    1. Remove the parking brake shoe return tension spring.
      GTY322424Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  16. REMOVE PARKING BRAKE SHOE LEVER 
    1. Using needle-nose pliers, remove the parking brake shoe lever from the No. 3 parking brake cable assembly as shown in the illustration.
      GTY317225Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  17. REMOVE PARKING BRAKE SHOE HOLD DOWN SPRING PIN 
    1. Remove the parking brake shoe hold down spring pin (for front side).
      GTY317226Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    2. Remove the parking brake shoe hold down spring pin (for rear side).
      GTY317228Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
scientia non olet · About LEMON Manuals