Problem Symptoms Table
WARNING: This page is about a different variant/trim than selected.
Use the table below to help determine the cause of problem symptoms. If multiple suspected areas are listed, the potential causes of the symptoms are listed in order of probability in the "Suspected Area" column of the table. Check each symptom by checking the suspected areas in the order they are listed. Replace parts as necessary.
Clutch System
PROBLEM SYMPTOMS REFERENCE
| Symptom | Suspected Area | See |
|---|---|---|
| Clutch grabs/chatters | Engine mounting (Loose) | - |
| Clutch disc assembly (Excessive runout) | INSPECTION | |
| Clutch disc assembly (Oily) | INSPECTION | |
| Clutch disc assembly (Worn out) | INSPECTION | |
| Clutch disc torsion spring (Damaged) | INSPECTION | |
| Clutch disc assembly (Glazed) | INSPECTION | |
| Diaphragm spring (Tip out of alignment) | INSPECTION | |
| Clutch pedal spongy | Clutch line (Air in line) | ON-VEHICLE INSPECTION |
| Master cylinder (Damaged) | CLUTCH MASTER CYLINDER | |
| Release cylinder piston (Damaged) | REMOVAL | |
| Clutch noisy | Clutch release bearing assembly (Worn, dirty or damaged) | INSPECTION |
| Clutch disc torsion spring (Damaged) | INSPECTION | |
| Clutch slips | Clutch pedal (Free play out of adjustment) | ADJUSTMENT |
| Clutch disc assembly (Oily) | INSPECTION | |
| Clutch disc assembly (Worn out) | INSPECTION | |
| Diaphragm spring (Damaged) | INSPECTION | |
| Pressure plate (Distorted) | INSPECTION | |
| Flywheel sub-assembly (Distorted) | INSPECTION | |
| Clutch does not disengage fully | Clutch pedal (Free play out of adjustment) | ADJUSTMENT |
| Clutch line (Air in line) | ON-VEHICLE INSPECTION | |
| Master cylinder (Damaged) | CLUTCH MASTER CYLINDER | |
| Release cylinder piston (Damaged) | REMOVAL | |
| Clutch disc assembly (Out of line) | INSPECTION | |
| Clutch disc assembly (Excessive runout) | INSPECTION | |
| Clutch disc assembly (Lining broken) | INSPECTION | |
| Clutch disc assembly (Dirty or burned) | INSPECTION | |
| Clutch disc assembly (Oily) | INSPECTION | |
| Clutch disc assembly (Lack of spline grease) | INSPECTION |