LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2009 >> Corolla S, 1.8 L, Standard >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 9 (Engine Intake / Exhaust Assembly (2AZ-FE)) >> Intake Manifold >> Removal

Intake Manifold: Removal

WARNING: This page is about a different variant/trim than selected.
  1. DISCHARGE FUEL SYSTEM PRESSURE 

    (See FUEL SYSTEM )

  2. DISCONNECT CABLE FROM NEGATIVE BATTERY TERMINAL 
  3. REMOVE NO. 1 ENGINE COVER SUB-ASSEMBLY  (See REMOVAL )
  4. DRAIN ENGINE COOLANT  (See COOLANT )
  5. REMOVE FRONT WIPER ARM HEAD CAP  (See ON-VEHICLE INSPECTION )
  6. REMOVE FRONT WIPER ARM AND BLADE ASSEMBLY LH  (See ON-VEHICLE INSPECTION )
  7. REMOVE FRONT WIPER ARM AND BLADE ASSEMBLY RH  (See REMOVAL )
  8. REMOVE HOOD TO COWL TOP SEAL  (See REMOVAL )
  9. REMOVE CENTER NO. 1 COWL TOP VENTILATOR LOUVER  (See REMOVAL )
  10. REMOVE COWL TOP VENTILATOR LOUVER LH  (See REMOVAL )
  11. REMOVE WINDSHIELD WIPER MOTOR AND LINK ASSEMBLY  (See REMOVAL )
  12. REMOVE OUTER COWL TOP PANEL  (See REMOVAL )
  13. REMOVE SUSPENSION TOWER DAMPER ASSEMBLY (w/ Front Strut Bar)  (See REMOVAL )
  14. REMOVE AIR CLEANER CAP SUB-ASSEMBLY WITH HOSE  (See ON-VEHICLE INSPECTION )
  15. REMOVE AIR CLEANER CASE SUB-ASSEMBLY  (See REMOVAL )
  16. REMOVE THROTTLE BODY ASSEMBLY  (See REMOVAL )
  17. DISCONNECT FUEL MAIN TUBE  (See REMOVAL )
  18. DISCONNECT NO. 2 VENTILATION HOSE  (See REMOVAL )
  19. REMOVE FUEL DELIVERY PIPE WITH INJECTOR  (See REMOVAL )
  20. REMOVE INTAKE MANIFOLD 
    1. Disconnect the union to connector tube hose from the No. 2 hose to hose tube.
    2. Disconnect the camshaft timing oil control valve connector.
    3. Remove the wire harness clamp.
    4. Remove the union to connector tube hose from the vacuum hose clamp.
    5. Remove the 5 bolts, 2 nuts and intake manifold.
      Fig 1: Locating Bolts, Nuts And Intake Manifold
      G06009191Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    6. Remove the gasket from the intake manifold.
      Fig 2: Identifying Gasket
      G04973392Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
scientia non olet · About LEMON Manuals