LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2008 >> Highlander Base, AWD >> Repair and Diagnosis >> Restraints >> Seat Belts >> Seat Belt (Except Hybrid) >> Rear No. 2 Seat Outer Belt Assembly >> Removal

Rear No. 2 Seat Outer Belt Assembly: Removal

  1. REMOVE REAR DOOR SCUFF PLATE  (See REMOVAL )
  2. DISCONNECT REAR DOOR OPENING TRIM WEATHERSTRIP 
  3. REMOVE DECK BOARD ASSEMBLY  (See REMOVAL )
  4. REMOVE NO. 3 DECK BOARD SUB-ASSEMBLY  (See REMOVAL )
  5. REMOVE NO. 2 DECK BOARD SUB-ASSEMBLY  (See REMOVAL )
  6. REMOVE TONNEAU COVER ASSEMBLY (w/ Tonneau Cover)  (See REMOVAL )
  7. REMOVE REAR SEAT SIDE COVER LH  (See REMOVAL )
  8. REMOVE DECK SIDE TRIM BOX LH  (See REMOVAL )
  9. REMOVE REAR SEAT SIDE COVER RH  (See REMOVAL )
  10. REMOVE JACK CARRIER SUPPORT 
  11. REMOVE JACK CARRIER CUSHION  (See REMOVAL )
  12. REMOVE JACK ASSEMBLY  (See REMOVAL )
  13. REMOVE JACK CARRIER ASSEMBLY  (See REMOVAL )
  14. REMOVE DECK SIDE TRIM BOX RH  (See REMOVAL )
  15. REMOVE REAR MAT  (See REMOVAL )
  16. REMOVE DECK FLOOR BOARD ASSEMBLY  (See REMOVAL )
  17. REMOVE REAR NO. 2 SEAT INNER BELT ASSEMBLY  (See REMOVAL  )
  18. DISCONNECT REAR SEAT LAP TYPE BELT ASSEMBLY LH 
    1. Remove the bolt and disconnect the rear seat lap type belt assembly LH.
      Fig 1: Identifying Rear Seat Lap Type Belt Assembly LH Bolt
      G05419471Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  19. DISCONNECT REAR SEAT LAP TYPE BELT ASSEMBLY RH 

    HINT:

    Use the same procedure for the RH side and the LH side.

  20. REMOVE REAR NO. 2 SEAT ASSEMBLY  (See REMOVAL )
  21. REMOVE REAR FLOOR FINISH PLATE  (See REMOVAL )
  22. REMOVE REAR SEAT SIDE GARNISH CAP (for RH Side without Rear Air Conditioning System)  (See REMOVAL )
  23. REMOVE REAR SEAT SIDE GARNISH CAP (for RH Side with Rear Air Conditioning System)  (See REMOVAL )
  24. REMOVE DECK SIDE TRIM COVER  (See REMOVAL )
  25. REMOVE DECK SIDE TRIM  (See REMOVAL )
  26. REMOVE SIDE TRIM COVER LH (for LH Side without Rear Seat Entertainment System)  (See REMOVAL )
  27. REMOVE POWER OUTLET SOCKET BEZEL (for LH Side with Rear Seat Entertainment System)  (See REMOVAL )
  28. REMOVE SIDE TRIM COVER RH (for RH Side without Rear Automatic Air Conditioning System)  (See REMOVAL )
  29. REMOVE REAR ROOM TEMPERATURE SENSOR (for RH Side with Rear Automatic Air Conditioning System)  (See REMOVAL )
  30. REMOVE REAR COMBINATION LIGHT SERVICE COVER LH (for LH Side)  (See REMOVAL )
  31. REMOVE REAR COMBINATION LIGHT SERVICE COVER RH (for RH Side)  (See REMOVAL )
  32. REMOVE REAR POWER POINT SOCKET ASSEMBLY (for LH Side)  (See REMOVAL )
  33. REMOVE REAR POWER OUTLET SOCKET COVER (for LH Side)  (See REMOVAL )
  34. REMOVE REAR DECK TRIM COVER (for LH Side without Remote Folding Function)  (See REMOVAL )
  35. REMOVE RECLINING REMOTE CONTROL LEVER BEZEL LH (for LH Side with Remote Folding Function)  (See REMOVAL )
  36. REMOVE ROPE HOOK ASSEMBLY  (See REMOVAL )
  37. REMOVE NO. 2 DECK SIDE TRIM HOOK (for LH Side)  (See REMOVAL )
  38. REMOVE NO. 1 LUGGAGE COMPARTMENT TRIM HOOK (for RH Side)  (See REMOVAL )
  39. REMOVE FRONT DECK SIDE TRIM COVER  (See REMOVAL )
  40. REMOVE DECK TRIM SIDE PANEL ASSEMBLY LH (for LH Side)  (See REMOVAL )
  41. REMOVE DECK TRIM SIDE PANEL ASSEMBLY RH (for RH Side)  (See REMOVAL )
  42. REMOVE ROOF SIDE INNER GARNISH ASSEMBLY (w/o Power Back Door)  (See REMOVAL )
  43. REMOVE ROOF SIDE INNER GARNISH ASSEMBLY (w/ Power Back Door)  (See REMOVAL )
  44. REMOVE REAR NO. 2 SEAT OUTER BELT ASSEMBLY 
    1. Remove the bolt and disconnect the shoulder end of the rear No. 2 seat outer belt assembly.
      Fig 2: Identifying Bolt & Shoulder End Of Rear No. 2 Seat Outer Belt Assembly
      G05419472Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    2. Remove the 2 bolts and the rear No. 2 seat outer belt assembly.
      Fig 3: Identifying Rear No. 2 Seat Outer Belt Assembly Bolts
      G05419473Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
scientia non olet · About LEMON Manuals