LEMON Manuals: Even more car manuals for everyone
Home >> Suzuki >> 2001 >> XL-7 Limited >> Repair and Diagnosis >> External Pages >> Different car >> Section 95 (Diagnosis - A/T) >> Diagnostic Information and Procedures >> DTC P0741, P0742 (No. 78/77): TCC Circuit Performance or Stuck OFF/ TCC Circuit Stuck ON >> Diagnostic Trouble Codes Confirmation Procedure

Diagnostic Trouble Codes Confirmation Procedure

WARNING: This page is about a different car, the 2004 Suzuki XL-7. However, it is still accessible from the selected car via links, so may be relevant.
WARNING:
  • When performing a road test, select a place where there is no traffic or possibility of a traffic accident and be very careful during testing to avoid occurrence of an accident.
  • Road test should be carried out with 2 persons, a driver and tester, on a level road.
  1. Connect scan tool to DLC with ignition switch OFF.
  2. Clear DTCs in TCM and ECM memories by using scan tool.
  3. Start engine and warm it up to normal operating temperature.
  4. Shift select lever to "N" and "D" range for each 10 seconds.
  5. Drive vehicle with 5th in "D" range and lock-up ON for 20 seconds or longer referring to AUTOMATIC GEAR SHIFT DIAGRAM (4 A/T) or Automatic Gear Shift Diagram  (5 A/T).
  6. Turn O/D OFF switch ON keeping on driving in "D" range. (Confirm "O/D OFF" lamp lights.)
  7. Drive vehicle with 2nd or 3rd gear in "D" range, 15 - 20 % throttle opening and at vehicle speed of 40 km/h (25 mile/h).
  8. Stop vehicle and turn ignition switch OFF.
  9. Repeat Step  3 - 7 one time.
  10. Stop vehicle.
  11. Check DTC, pending DTC and freeze-frame data.
scientia non olet · About LEMON Manuals