Pilot Line Test
WARNING: This page is about a different variant/trim than selected.
| Measurement as in 2X00IN | Measuring point | Actual values | Required |
|---|---|---|---|
| Measurement 1 | Connector for high-voltage battery control unit | Ohm | ≤ 10 Ohm |
| Measurement 1.1 | Connector for high-voltage battery control unit → 12 V connector for E-box | Ohm | ≤ 0.5 Ohm |
| Measurement 2 | Connector for high-voltage battery control unit → 12 V connector for electric passenger compartment heater | Ohm | < 1.0 Ohm |
| Measurement 2.1 | Connection for electric passenger compartment heater | Ohm | ≤ 0.5 Ohm |
| Measurement 2.2 | High-voltage line for plug bridge for electric passenger compartment heater | Ohm | ≤ 0.5 Ohm |
| Measurement 3 | 12 V connector for electric passenger compartment heater → service disconnector | Ohm | ≤ 1.5 Ohm |
| Measurement 3.1 | 12 V connector for electric passenger compartment heater → connection point for engine wire harness | Ohm | ≤ 0.5 Ohm |
| Measurement 3.2 | Connection point for engine wire harness (female) → wire harness for air-conditioning compressor | Ohm | ≤ 0.5 Ohm |
| Measurement 3.2.1 | Connection point for engine wire harness → 12 V connector for air-conditioning compressor (GE/GE) | Ohm | ≤ 1.0 Ohm |
| Measurement 3.2.2 | Connection point for engine wire harness → 12 V connector for air-conditioning compressor (GE/SW) | Ohm | ≤ 1.0 Ohm |
| Measurement 3.2.3 | High-voltage line for plug bridge for A/C compressor | Ohm | ≤ 0.5 Ohm |
| Measurement 3.3 | 12 V connector for air-conditioning compressor → service disconnector | Ohm | ≤ 1.0 Ohm |
| Measurement 4 | Service disconnector → 12 V connector for E-Box | Ohm | ≤ 1.0 Ohm |
| Measurement 4.1 | High-voltage line for plug bridge from E-box to high-voltage charger (E-box) | Ohm | ≤ 0.5 Ohm |
| Measurement 5 | High-voltage line for plug bridge for electric passenger compartment heater (high-voltage charger) | Ohm | ≤ 0.5 Ohm |
| Measurement 5.1 | High-voltage line for plug bridge for A/C compressor (high-voltage charger) | Ohm | ≤ 0.5 Ohm |
| Measurement 5.2 | High-voltage line for plug bridge for E-box (high-voltage charger) | Ohm | ≤ 0.5 Ohm |
| Measurement 5.3 | High-voltage line for plug bridge for charging socket (high-voltage charger) | Ohm | ≤ 0.5 Ohm |
| Measurement 6 | 12 V connector for plug bridge for power electronics | Ohm | ≤ 0.5 Ohm |
Sign the test log and file it in the order folder.
Signature: _________