LEMON Manuals: Even more car manuals for everyone
Home >> Porsche >> 2016 >> 911 Turbo, 2D Convertible >> Repair and Diagnosis >> External Pages >> Different car >> Section 36 (Linings, Insulation - 911 CARRERA (996)) >> Disassembling and assembling the dashboard - as of MY 1997 >> Disassembling the dashboard >> Notes

Disassembling the dashboard: Notes

WARNING: This page does not describe the selected car, but rather 7 other vehicles, including the 2005 Porsche 911, 2004 Porsche 911, 2003 Porsche 911, 2002 Porsche 911, and 2001 Porsche 911. However, it is still accessible from the selected car via links, so may be relevant.
Fig 1: Disassembling Dashboard (Steps 1-5) (As Of MY 1997)
G03105994Courtesy of PORSCHE OF NORTH AMERICA, INC.
DASHBOARD DISASSEMBLING PROCEDURE (STEPS 1-5) (AS OF MY 1997)

No. Procedure Instructions
  Removing the A-pillar trim Refer to Removing and installing trim of A, B and C-pillars, - as of MY 1997  .
  Removing the driver's airbag Refer to REMOVING AND INSTALLING THE DRIVER'S AIRBAG UNIT .
  Removing passenger's airbag Refer to REMOVING AND INSTALLING THE PASSENGER'S AIRBAG UNIT .
1 Removing the alarm readiness cover and the defroster cover Lift the alarm readiness cover -3-4-2-5, 6-4-  . See Fig 1 .
2 Removing the alarm readiness unit Undo the fastening screws -7-8-  . See Fig 1 .
3 Removing the loudspeaker Undo the fastening screws -9-10-11-arrow-  . See Fig 1 .
4 Removing the instrument mount To remove the hazard warning light switch: switch on the switch -12-arrow A-13-17-arrow B-14-15-16-17-4-  . See Fig 1 .
5 Disconnecting the electrical plug connection Disconnect the electrical connection -18-direction of the arrow-  . See Fig 1 .
Fig 2: Disassembling Dashboard (Steps 6-10) (As Of MY 1997)
G03105995Courtesy of PORSCHE OF NORTH AMERICA, INC.
DASHBOARD DISASSEMBLING PROCEDURE (STEPS 6-10) (AS OF MY 1997)

No. Procedure Instructions
6 Removing the side vents and the temperature sensor Pull off the covering caps -20, 20A-21-22-24-23-  . See Fig 2 .
7 Removing left side vents and main light switch Pull forward the control button -25-31-direction of the arrow-21-30-31-28-26-27-31-31-  . See Fig 2 .
8 Removing the steering column switch cover Undo the fastening screws -32-36-33, 36 or 35-  . See Fig 2 .
9 Removing the steering column switch Undo the fastening screw -37-38-42-42-41-39,40-  . See Fig 2 .
    Refer to REMOVING AND INSTALLING THE CONTACT UNIT .
10 Removing the steering column cover Undo the fastening screw -43-44-  . See Fig 2 .
Fig 3: Disassembling Dashboard (Steps 11-15) (As Of MY 1997)
G03105996Courtesy of PORSCHE OF NORTH AMERICA, INC.
DASHBOARD DISASSEMBLING PROCEDURE (STEPS 11-15) (AS OF MY 1997)

No. Procedure Instructions
11 Removing the switch cover Unclip the switch cover on the left and right -45, 46-  . See Fig 3 .
12 Removing the electrical air-conditioning and heating regulator variant -47-48, 49-  . See Fig 3 . Refer to REMOVING AND INSTALLING HEATING/AIR-CONDITIONING CONTROL and RADIO - 911 CARRERA (996) .
13 Removing display and operator control unit -50-  . See Fig 3 . Press in and hold both spring clips -arrow A-50-51-  . See Fig 3 .
  (PCM)-50-  . See Fig 3 . Refer to REMOVING AND INSTALLING DISPLAY AND OPERATOR CONTROL UNIT (PCM) .
14 Removing the PCM retaining bracket Raise the retaining clip -arrow B-52-55-53-  . See Fig 3 .
15 Removing the central vent Undo the fastening screws -54-55-1-56-57-  . See Fig 3 .
scientia non olet · About LEMON Manuals