Subsequent Work

Information 

• Following replacement of the high-pressure pump and engine, the values for the high-pressure adaptation must be reset using the PI WIS Tester. Then carry out a test and adaptation drive. Read the information in the portion 

  > 24701900 REMOVING AND INSTALLING DME (DFI) CONTROL UNIT .

• The current software must be installed on the control unit if necessary. Following conversion to a new engine, it is possible that an old software version may still be installed on the control unit. 

1. Install front left wheel housing liner completely on vehicles with PDCC.

   > WM 505619 REMOVING AND INSTALLING FRONT WHEEL HOUSING LINER (EXCEPT PANAMERA S EXECUTIVE, PANAMERA EXECUTIVE, PANAMERA 4 S EXECUTIVE, PANAMERA TURBO EXECUTIVE, PANAMERA TURBO S, PANAMERA TURBO S EXECUTIVE, PANAMERA GTS, PANAMERA 4S SPORT EDITION, PANAMERA

2. Install front part of front wheel housing liner on both sides.

   > WM 505619 REMOVING AND INSTALLING FRONT WHEEL HOUSING LINER (EXCEPT PANAMERA S EXECUTIVE, PANAMERA EXECUTIVE, PANAMERA 4 S EXECUTIVE, PANAMERA TURBO EXECUTIVE, PANAMERA TURBO S, PANAMERA TURBO S EXECUTIVE, PANAMERA GTS, PANAMERA 4S SPORT EDITION, PANAMERA

3. Fasten brake calliper on both sides.

   > WM 473919 REMOVING AND INSTALLING FRONT BRAKE CALLIPER (ALL MODELS)

   > WM 473919 REMOVING AND INSTALLING FRONT BRAKE CALLIPER (PCCB) (ALL MODELS)

4. Install cardan shaft.

   > WM 393519 REMOVING AND INSTALLING REAR CARDAN SHAFT (EXCEPT PANAMERA S E-HYBRID, PANAMERA S HYBRID, PANAMERA GTS, PANAMERA 4S SPORT EDITION, PANAMERA 4 EXECUTIVE)

5. Install exhaust system.

   > 260119 REMOVING AND REINSTALLING EXHAUST SYSTEM

6. Install underbody panelling.

   > WM 519219 REMOVING AND INSTALLING COVER FOR FRONT UNDERBODY (PANAMERA, PANAMERA S, PANAMERA S EXECUTIVE, PANAMERA 4, PANAMERA 4S, PANAMERA 4 S EXECUTIVE, PANAMERA TURBO S)

   > WM 519319 REMOVING AND INSTALLING COVER FOR CENTRE UNDERBODY (EXCEPT PANAMERA S EXECUTIVE, PANAMERA EXECUTIVE, PANAMERA 4 S EXECUTIVE, PANAMERA TURBO EXECUTIVE, PANAMERA TURBO S EXECUTIVE, PANAMERA GTS, PANAMERA 4S SPORT EDITION, PANAMERA 4 EXECUTIVE)

   > WM 519419 REMOVING AND INSTALLING COVER FOR REAR UNDERBODY (EXCEPT PANAMERA EXECUTIVE, PANAMERA 4 S EXECUTIVE, PANAMERA TURBO EXECUTIVE, PANAMERA TURBO S EXECUTIVE, PANAMERA GTS, PANAMERA 4S SPORT EDITION, PANAMERA 4 EXECUTIVE)

7. Install rear profile seal.

   > WM 553319 REMOVING AND INSTALLING FRONT LID SEAL (EXCEPT PANAMERA EXECUTIVE, PANAMERA 4S SPORT EDITION, PANAMERA 4 EXECUTIVE)

8. Install plenum panel cover.

   > WM 852219 REMOVING AND INSTALLING PLENUM PANEL COVER (EXCEPT PANAMERA S EXECUTIVE, PANAMERA EXECUTIVE, PANAMERA 4 S EXECUTIVE, PANAMERA TURBO EXECUTIVE, PANAMERA GTS, PANAMERA 4S SPORT EDITION, PANAMERA 4 EXECUTIVE)

9. Install cowl panel covering.

   > WM 508719 REMOVING AND INSTALLING COWL PANEL COVER (EXCEPT PANAMERA EXECUTIVE, PANAMERA 4S SPORT EDITION, PANAMERA 4 EXECUTIVE)

10. Connect battery ground strap.

    > 9X00IN Work instructions after disconnecting the battery. Refer to appropriate procedure in 9X - ELECTRICAL SYSTEM - GENERAL -- PANAMERA (970)

11. Fill up coolant.

    > 193817 DRAINING AND FILLING COOLANT

12. Fill up refrigerant for the air conditioning system.

    > WM 870317 DRAINING AND FILLING REFRIGERANT (EXCEPT PANAMERA S EXECUTIVE, PANAMERA EXECUTIVE, PANAMERA 4 S EXECUTIVE, PANAMERA TURBO EXECUTIVE, PANAMERA GTS, PANAMERA 4S SPORT EDITION, PANAMERA 4 EXECUTIVE)

13. Fill the hydraulic oil tank.

    > WM 430955 REPLACING RESERVOIR (PDCC) (EXCEPT PANAMERA EXECUTIVE, PANAMERA 4 S EXECUTIVE, PANAMERA TURBO EXECUTIVE, PANAMERA TURBO S, PANAMERA TURBO S EXECUTIVE, PANAMERA GTS, PANAMERA 4S SPORT EDITION, PANAMERA 4 EXECUTIVE)

    > Refer to 489755 Replacing reservoir

14. Bleed the power steering.

    > WM 480201 CHECKING HYDRAULIC FLUID (FLUID LEVEL) (EXCEPT PANAMERA GTS, PANAMERA TURBO S, PANAMERA PLATINUM ED., PANAMERA 4 PLATINUM ED.)

15. Check ATF level.

    > WM 370235 CHECKING AND TOPPING UP ATF (PANAMERA S E-HYBRID, PANAMERA S HYBRID)

16. Check engine-oil level.

    > 170101 CHECKING ENGINE-OIL LEVEL

17. Perform suspension alignment.

    > 449503 Suspension alignment, complete. Refer to appropriate information in 44 - WHEELS, TIRES, SUSPENSION ALIGNMENT -- PANAMERA (970)

18. Adjust the locking cable.

    > WM 371315 ADJUSTING LOCKING CABLE (EXCEPT PANAMERA S EXECUTIVE, PANAMERA EXECUTIVE, PANAMERA 4 S EXECUTIVE, PANAMERA TURBO EXECUTIVE, PANAMERA TURBO S EXECUTIVE, PANAMERA GTS, PANAMERA 4S SPORT EDITION, PANAMERA 4 EXECUTIVE)

19. Perform a test drive.

    After the cooling system has cooled down, check the engine coolant level in the reservoir and top up to the max. mark if necessary.