LEMON Manuals: Even more car manuals for everyone
Home >> Porsche >> 2011 >> 911 Speedster >> Repair and Diagnosis >> External Pages >> Different car >> Section 8 (Radio, Navigation & Pcm Diagnosis - 911 CARRERA (996)) >> 8005 External BOSE amplifier >> Diagnosis/troubleshooting - BOSE

Diagnosis/troubleshooting - BOSE

WARNING: This page does not describe the selected car, but rather 7 other vehicles, including the 2005 Porsche 911, 2004 Porsche 911, 2003 Porsche 911, 2002 Porsche 911, and 2001 Porsche 911. However, it is still accessible from the selected car via links, so may be relevant.
DIAGNOSIS/TROUBLESHOOTING (8005 EXTERNAL BOSE AMPLIFIER)

Work instruction Display OK If not Ok
1 Check the rear left and right wiring harness and loudspeakers and the right door speaker
  • Connect and start the Porsche System Tester II 9588 and switch on the ignition.
  • Select 911 (996) in the Vehicle type menu and confirm with the "FORWORD" key.
  • Select PCM in the Control units menu and confirm with the "FORWORD" key.
  • Select External BOSE amplifier in the 911 (996) PCM2 function selection and confirm with the "FORWORD" key.
  • Select Fault memory in the 911 (996) external BOSE amplifier function selection and confirm with the "FORWORD" key.
  • Read out fault memory.
  • Erase fault memory.
  • Remove ignition key and switch on ignition again.
  • Read out fault memory.
  • Extract ambient data, press the "FORWORD" key.
 -> End Fault code is still displayed
Step 2
2 Check wiring harness and loudspeaker for the right door speaker
  • Switch off ignition.
  • Pull off plug A on the amplifier.
  • Measure resistance on plug A, pins 26 and 31.
 = 4
Step 10		 Step 4
3 Check the rear left and right wiring harness and loudspeakers
  • Switch off ignition.
  • Pull off plug A on the amplifier.
  • Check resistance on plug A, pins 23 and 28.
 = 4
Step 3		 Step 6
4 Check right door speaker wire
  • Pull off the plugs on the loudspeakers.
  • Check the resistance in the wire between pin 26 on plug A of the amplifier and pin 2 of the plug for the front right door speaker.
 < 5
Step 5		 Open circuit in the wire/short circuit to ground. Repair wiring harness
-> End
5 Check right door speaker wire
  • Check the resistance in the wire between pin 31 on plug A of the amplifier and pin 1 of the plug for the front right door speaker.
 < 5
Step 8		 Open circuit in the wire/short circuit to ground. Repair wiring harness
-> End
6 Check the rear left and right loudspeaker wire
  • Check the resistance in the wire between pin 23 on plug A of the amplifier and pin 3 of the plug for the rear left and right loudspeaker.
 < 0.5
Step 7		 Open circuit in the wire/short circuit to ground. Repair wiring harnes
> End
7 Check the rear left and right loudspeaker wire
  • Check the resistance in the wire between pin 28 on plug A of the amplifier and pin 4 of the plug for the rear left and rear right loudspeaker.
 < 0.5
Step 9		 Open circuit in the wire/short circuit to ground. Repair wiring harnes
->End
8 Replace front left loudspeaker -> End Step 10
9 Replace the rear left and right loudspeakers -> End Step 10
10 Replace amplifier -> End  
scientia non olet · About LEMON Manuals