Front Side Door Replacement

WARNING: This page is about a different car, the 2009 Pontiac Torrent and 2009 Chevrolet Equinox. However, it is still accessible from the selected car via links, so may be relevant.

Fig 1: View Of Front Side Door Hinge

Courtesy of GENERAL MOTORS CORP.

Callout	Component Name
WARNING: In order to prevent SIR deployment, personal injury, or unnecessary SIR system repairs, do not strike the door or the door pillar in the area of the side impact sensor (SIS). Turn OFF the ignition and remove the key when performing service in the area of the SIS. Preliminary Procedures Disable the supplemental inflatable restraint (SIR) system. Refer to SIR Disabling and Enabling . Remove the front door trim panel. Refer to Front Side Door Trim Panel Replacement .
1	Front Side Door Check Link Bolt CAUTION: Refer to Fastener Caution . Tighten: 20 N.m (15 lb ft)
2	Front Side Door Upper Hinge Bolt (Qty: 2) Procedure Remove the water deflector. Support the door before removing the hinge bolts. Disconnect the electrical connector. With the aid of an assistant, remove the door. Tighten: 25 N.m (18 lb ft)
3	Front Side Door Lower Hinge Bolt (Qty: 2) Tighten: 25 N.m (18 lb ft)
4	Front Side Door Assembly Procedure When replacing the door it is necessary to transfer all of the internal components. Apply LOCTITE® Blue GM P/N 12345382, or (Canadian P/N 10953489), or equivalent to the fastener prior to installation. Verify door is properly aligned. If door adjustments are needed, refer to Front Side Door Adjustment .