Body Equipment - Repair (R56) -- Cooper
- Safety And General Information
- 51 00... Safety information for working on vehicles with airbag systems
- 00 Safety information for working on vehicles with automatic engine start-stop function (MSA)
- 51 00... Notes on component bonding with adhesive tape
- 51 00... Notes on film bonding
- 51 00... Notes on installing rubber window seals
- 41 00... Replacing bolts
- 41 00... Replacing blind rivets
- 51 00... Overview of consumables
- Front Bumper
- 51 11.. Overview of front bumper
- 51 11... Installing/replacing number plate (without number plate baseplate)
- 51 11 152 Remove and install/replace the center spoiler on bumper panel
- 51 11 156 Removing and installing front bumper panel
- 51 11... Removing and installing/replacing air inlet frame for braking air channel, left or right
- 51 11 300 Removing and installing/replacing center cover
- 51 11... Removing and installing/replacing cover for headlight washer unit on left
- 51 11 180 Removing and installing/replacing ornamental grille in bumper panel
- 51 11 050 Removing and installing/replacing support for front bumper panel
- 51 11 164 Removing and installing/replacing trim for bumper trim on left or right
- 51 11 157 Replace bumper panel, front
- Rear Bumper
- 51 12.. Overview of rear bumper
- 51 12 156 Removing and installing rear bumper panel (from production date 08/2010)
- 51 12 156 Removing and installing rear bumper panel (until production date 08/2010)
- 51 12... Removing and installing/replacing frame for rear fog lights left or right
- 51 12 825 Removing and installing/replacing guide for rear center bumper
- 51 12 090 Removing and installing/replacing ornamental grille in bumper trim (Cooper S/SD)
- 51 12 050 Removing and installing/replacing support for rear bumper panel
- 51 12 070 Replace the center spoiler on rear bumper panel
- 51 12 801 Replacing holder for rear bumper at left or right
- 51 12 157 Replacing rear bumper panel
- Trim, Covers, Handle Trim
- 51 13... Decal stripes on engine compartment lid
- 51 13 102 Removing and installing/replacing cover on front left or right wheel arch
- 51 13 425 Removing and installing/replacing cover on left or right rear light
- 51 13 022 Removing and installing/replacing engine compartment lid air guide
- 51 13 000 Removing and installing/replacing front grillE center section
- 51 13 091 Removing and installing/replacing front side panel trim strip, left or right
- 51 13 402 Removing and installing/replacing handle strip (tailgate)
- 51 13 123 Removing and installing/replacing left cowl panel cover
- 51 13 301 Removing and installing/replacing left or right roof trim strip
- 51 13 124 Removing and installing/replacing right cowl panel cover
- 51 13 003 Removing and installing/replacing trim on front grille
- 51 13 375 Removing and installing/replacing trim on left or right rear roof pillar (C-pillar)
- 51 13 105 Removing and installing/replacing trim on rear left or right wheel arch
- 51 13 015 Removing and installing/replacing trim ring for left or right headlight
- 51 13 009 Removing and installing/replacing trim strip on engine compartment lid
- 51 13 085 Removing and installing/replacing trim strip on engine compartment lid (cowl panel)
- BMW Emblems, Model Emblems
- 51 14... General notes for labelling with adhesive films
- 51 14... Instructions for attaching number/letter designation combination
- 51 14 002 Removing and installing/replacing front MINI badge
- 51 14 012 Removing and installing/replacing rear MINI badge
- 51 14 110 Removing and installing/replacing rear model designation
- Mirrors/Covers/Ashtrays/Shelves/Trays
- 51 16... Calibrating the compass on the inside mirror
- 51 16 480 Removing and installing or replacing front grab handle
- 51 16 060 Removing and installing or replacing inside mirror
- 51 16 000 Removing and installing or replacing mirror on left or right front door
- 51 16 080 Removing and installing or replacing sun visor and left or right counter support
- 51 16 206 Removing and installing/replacing center armrest
- 51 16 160 Removing and installing/replacing center console trim
- 51 16 196 Removing and installing/replacing cover (armrest) for center armrest
- 51 16... Removing and installing/replacing damper for glovebox
- 51 16 345 Removing and installing/replacing glovebox button
- 51 16 365 Removing and installing/replacing glovebox lid
- 51 16... Removing and installing/replacing holder for inside mirror
- 51 16 342 Removing and installing/replacing lock barrel for front passenger airbag deactivation
- 51 16 340 Removing and installing/replacing lock for right glovebox
- 51 16 041 Removing and installing/replacing protective cap on left or right exterior mirror
- 51 16 450 Removing and installing/replacing rear left/right grab handle
- 51 16 218 Removing and installing/replacing rear storage compartment holder
- 51 16 200 Removing and installing/replacing storage compartment
- 51 16 085 Removing and installing/replacing sun visor and counter-support on driver's side (side)
- 51 16 026 Replacing mirror glass
- Front Door Locks, Handles, Fittings
- 51 21 004 Adjusting front left or right lock striker
- 51 21 150 Blocking, if necessary initializing, car key in immobilizer control module
- 51 21 280 Removing and installing or replacing door brake on left or right front door
- 51 21 225 Removing and installing or replacing inside door opener in left or right front door
- 51 21 170 Removing and installing or replacing outside handle from left or right front door
- 51 21 235 Removing and installing/replacing Bowden cable for inside door opener on left or right front door
- 51 21 140 Removing and installing/replacing complete lock cylinder in left or right front door
- 51 21 370 Removing and installing/replacing cover at bottom left or right on front door
- 51 21 090 Removing and installing/replacing door lock in left or right front door
- 51 21 300 Removing and installing/replacing weather strip on outside of front door
- 51 21... Removing weather strip with special tool 00 9 324 at front or rear
- 51 21 003 Replacing door detent (lock striker), front left or right
- 51 21 351 Replacing window cavity cover strip on inside of front door
- Engine Compartment Lid Latch, Locks
- 51 23... Adjusting/replacing bump stops
- 51 23 200 Remove, install/replace lever with console for engine compartment lid catch
- 51 23 160 Removing and installing/replacing arrester hook on engine compartment lid
- 51 23 212 Removing and installing/replacing cable for front engine compartment lid locks (in passenger compartment)
- 51 23 215 Removing and installing/replacing cable for front engine compartment lid locks (in engine compartment) on right and left
- 51 23 110 Removing and installing/replacing left engine compartment lid lock
- 51 23 265 Removing and installing/replacing left or right gas strut for engine compartment lid
- 51 23 100 Removing and installing/replacing right engine compartment lid lock
- Trunk Latch, Locks
- Front And Rear Window
- 61 35... Overview, rain sensor (additional work when replacing the windscreen/sensor replacement)
- 51 31... Notes on window bonding
- 51 31... Materials for bonding window
- 51 31... General procedure for the disassembly and installation of bonded window glass
- 51 31... Notes on window bonding repair kit
- 51 31... Remove windscreen with "Roll Out 2000"
- 51 31 000 Removing and installing/renewing windscreen
- 51 31 284 Removing and installing/replacing lower cover on rear window
- 51 31 200 Removing and installing/replacing rear window
- 51 31... Removing and installing/replacing retaining strip for cowl panel cover
- 51 31 021 Removing and installing/replacing rubber frame for windscreen (top)
- 51 31 045 Removing and installing/replacing trim on A-pillar, left or right
- 51 31... Removing windows with a "Spider"
- 51 31... Removing windows with an oscillating knife
- 51 31 015 Repairing damage to windscreens caused by pitting (stone chips) (clear and tinted laminated safety glass)
- 51 31... Window glass removal with wire pull handle
- Front Windows
- Power Window Regulator
- Hinged Window
- Front Door Trim Panel With Arm Rest
- 51 41 060 Removing and installing (replacing) armrest on door trim panel, front left or right
- 51 41 000 Removing and installing (replacing) front left or right door trim panel
- 51 41 005 Removing and installing (replacing) left or right door trim panel carrier
- 51 41 017 Removing and installing or replacing cover on door handle, front left or right
- 51 41 019 Removing and installing or replacing door handle on door trim, front left or right
- 51 41 031 Replacing decorative strip on front left or right door trim panel
- 51 41... Replacing speaker trim (mid-range speaker) on left or right front door trim panel
- 51 41 018 Replacing speaker trim on left or right door trim panel (woofer)
- Side Covering With Armrests
- 51 43 201 Removing and installing or replacing trim for roof pillar at front (A-pillar), left or right
- 51 43 148 Removing and installing or replacing trim on left or right door pillar (top)
- 51 43 002 Removing and installing rear left or right side trim panel (JCWGP)
- 51 43 002 Removing and installing/replacing rear left or right side trim panel
- 51 43 251 Removing and installing/replacing trim panel for left or right rear roof pillar (C-pillar)
- 51 43 006 Replacing decorative strip on left or right side trim panel
- Roof Trim Panel
- Instrument Cluster Trim Panel
- 51 45.. Overview of dashboard
- 51 45 370 Removing and installing (replacing) left decorative strip on dashboard
- 51 45 180 Removing and installing (replacing) lower left instrument panel trim
- 51 45 380 Removing and installing (replacing) right decorative strip on instrument panel
- 51 45 072 Removing and installing dashboard with support
- 51 45 070 Removing and installing or replacing instrument panel lower section
- 51 45 075 Removing and installing support for dashboard
- 51 45 435 Removing and installing/replacing cover for instruments
- 51 45 108 Removing and installing/replacing function carrier on center console
- 51 45 050 Removing and installing/replacing instrument panel upper section trim
- 51 45 252 Removing and installing/replacing knee protection, driver's side, right
- 51 45 254 Removing and installing/replacing knee protection on front passenger side
- 51 45 250 Removing and installing/replacing knee protection, driver's side, left
- 51 45 430 Removing and installing/replacing side air vent cover, left (or right)
- 51 45... Removing and installing/replacing side center console panel
- 51 45... Removing and installing/replacing side cover from cover for air outlet vent
- 51 45 076 Replacing carrier for instrument panel
- Parcel Shelf Trim Panel/Roller Sun Blind
- Floor/Luggage Compartment/Engine Compartment Trim Panels
- 51 47 314 Removing and installing/replacing carpet for passenger compartment
- 51 47 490 Removing and installing/replacing front assembly underbody protection (diesel)
- 51 47 000 Removing and installing/replacing front left or right entrance cover strip
- 51 47 151 Removing and installing/replacing left luggage compartment wheel arch trim
- 51 47 101 Removing and installing/replacing luggage compartment floor trim panel
- 51 47 101 Removing and installing/replacing luggage compartment floor trim panel (front) (JCW GP)
- 51 47 161 Removing and installing/replacing right luggage compartment wheel arch panel
- 51 71... Removing and installing/replacing the load bar (JCW GP)
- Front Lid Insulation Lining
- Rear Lid Trim Panel
- Gaskets/Seals, Loose Body Components
- 51 71 040 Removing and installing/replacing front left or right wheel arch cover
- 51 71 426 Removing and installing/replacing panel for cover on left or right side member
- 51 71 041 Removing and installing/replacing rear left or right wheel arch cover
- 51 71 412 Removing and installing/replacing rear spoiler
- 51 71... Removing and installing/replacing rear underbody panelling
- 51 71... Removing and installing/replacing strut brace (JCW GP2)
- 51 71... Removing and installing/replacing the load bar (JCW GP)
- 51 71 418 Replacing cover on trim panel for cover on side member, left or right
- MUCKET For Doors
- Underbody Panelling