LEMON Manuals: Even more car manuals for everyone
Home >> Mini >> 2005 >> Cooper S, 2D Hatchback, Standard >> Repair and Diagnosis >> Body & Frame >> Sun Roof/T-Top/Convertible Top >> Slide/Tilt Roof - Repair Instructions - Cooper (R50) & Cooper S (R53) >> Mechanical run roof components >> 54 12 200 Removing and installing complete sunroof

54 12 200 Removing and installing complete sunroof

Remove headlining. Refer to 51 44 011 REMOVING AND INSTALLING/REPLACING HEADLINER (WITH SLIDE/TILT SUNROOF) .

Unclip and release harness (1) from interior light holder (2).

Fig 1: Locating Interior Light Holder Wiring Harness
G03306912Courtesy of BMW OF NORTH AMERICA, INC.

Release front drain tubes.

Fig 2: View Of Front Drain Tubes
G03306913Courtesy of BMW OF NORTH AMERICA, INC.

Release rear drain tubes.

Fig 3: Identifying Rear Drain Tubes
G03306914Courtesy of BMW OF NORTH AMERICA, INC.

Loosen 9 tolerance compensators (1).

Tightening torque, refer to 54 12 1AZ in SLIDE/TILT ROOF AND CONVERTIBLE TOP - TIGHTENING TORQUES - COOPER (1.6L) R50/W10 .

Fig 4: Locating Tolerance Compensators
G03306915Courtesy of BMW OF NORTH AMERICA, INC.

Disconnect connector (1)

Remove bolts (2).

Tightening torque, refer to 54 12 2AZ in SLIDE/TILT ROOF AND CONVERTIBLE TOP - TIGHTENING TORQUES - COOPER (1.6L) R50/W10 .

Fig 5: Disconnecting Connector
G03306916Courtesy of BMW OF NORTH AMERICA, INC.

Remove bolts (1).

Tightening torque, refer to 54 12 2AZ in SLIDE/TILT ROOF AND CONVERTIBLE TOP - TIGHTENING TORQUES - COOPER (1.6L) R50/W10 .

Fig 6: Identifying Retaining Bolts
G03306917Courtesy of BMW OF NORTH AMERICA, INC.
CAUTION: Sunroof will require three people for removal.

Loosen 4 height adjuster screws (1).

Remove sunroof.

Install Hint: 

Adjust sunroof. Refer to 54 12 004 ADJUSTING SUNROOF  .

Fig 7: Removing Sunroof
G03306918Courtesy of BMW OF NORTH AMERICA, INC.
NOTE:

A guide pin can be used at the front and rear of the sunroof, to aid positioning of sunroof to body when fitting.