LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2021 >> S500 >> Repair and Diagnosis >> Electrical >> Motors, Switches, Relays >> Electrical System, Equipment & Instruments (2 Of 3) -- 223 Chassis >> Testing & Repair >> Remove/Install Battery Sensor Of 12 V On-Board Electrical System >> Remove/Install Battery Sensor Of 12 V On-Board Electrical System - AR54.10-P-0062SA

Remove/Install Battery Sensor Of 12 V On-Board Electrical System - AR54.10-P-0062SA

Model 223 

with code ME10 (Hybrid vehicle (plug-in, PHEV)) 

G16191572Courtesy of MERCEDES-BENZ USA
DANGER Risk of fire  /risk of explosion due to short circuit and escaping oxyhydrogen gas. Risk of (burn) injury caused by caustic burns to eyes, skin and mucous membranes from battery electrolyte/mist, short circuit and arcing. Risk of poisoning  caused by swallowing battery electrolyte or absorption of lead through the skin or body orifices. Risk of death  due to voltage U >= 30 V AC and U >= 60 V DC. No fires, sparks, open flames, or smoking. Wear acid-resistant gloves, clothing, and glasses. Pour battery acid only into suitable and appropriately marked containers. AS54.10-Z-0001-01A 
CAUTION Risk of injury  caused by scraping or cutting body parts on sharp vehicle parts Always wear protective gloves when working on or near sharp and non-deburred vehicle parts.
Deburr repair panels.
AS00.00-Z-0017-01A
Notice  General information on vehicles with high-voltage on-board electrical system and/or lithium-ion battery and/or gaseous-fuel drive system as well as personal protective equipment   AH00.00-Z-0300-01A
Notice  Information on preventing damage to electronic components due to electrostatic discharge   AH54.00-P-0001-01A
Notice  Notes on battery   AH54.10-P-0001-01A
Notice  Notes on threaded connections fastened using a tightening angle-based tightening process   AH00.00-P-0020-01A
REMOVINGINSTALLING Remove/install     
1 Disconnect ground line (2) from on-board electrical system battery.   AR54.10-P-0051S 
2 Remove center strut above on-board electrical system battery. TORQUE SPECIFICATION Screw, center strut to longitudinal member mounting console *BA62.30-P-1009-02P 
    TORQUE SPECIFICATION Screw, center/lower strut to suspension strut tower mounting console *BA62.30-P-1008-02P 
3 Release electrical connector (1) and disconnect.    
4 Remove ground line (2) of battery sensor (B95) from body. IMPORTANT The ground line (2) and battery sensor (B95) are one component part and cannot be replaced individually.  
    TORQUE SPECIFICATION Powerpack ground point, tml.31 LHD vehicle *BA00.19-P-1001-01N 
    TORQUE SPECIFICATION Powerpack ground point, tml.31 RHD vehicle *BA00.19-P-1046-01N 
5 Install in the reverse order.    
6 Commission battery sensor (B95). If the battery sensor (B95) was replaced.  
REFER TO SELF-DIAGNOSTIC SYSTEMS     AD00.00-P-2000-06FR
GROUND POINTS

Number Designation Model 223 except code Z07 (B7 armoring on special protection version) Model 223 with code Z07 (B7 armoring on special protection version)
BA00.19-P-1001-01N Powerpack ground point, tml.31 LHD vehicle W106 Nm 7 7
GROUND POINTS

Number Designation Model 223 except code Z07 (B7 armoring on special protection version) Model 223 with code Z07 (B7 armoring on special protection version)
BA00.19-P-1046-01N Powerpack ground point, tml.31 RHD vehicle W106 Nm 16 16
FRONT AREA WITH FRONT REINFORCEMENT

Number Designation Model 223
BA62.30-P-1008-02P Screw, center/lower strut to suspension strut tower mounting console Stage 1   Nm 35
Stage 2   Nm 50
Stage 3 Loosen ∠° 180
Stage 4   Nm 50
FRONT AREA WITH FRONT REINFORCEMENT

Number Designation Model 223
BA62.30-P-1009-02P Screw, center strut to longitudinal member mounting console Nm 30