LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2019 >> S450 Base >> Repair and Diagnosis >> Body & Frame >> Windows >> Doors - 222 Chassis (1 Of 2) >> Testing & Repair >> Remove/Install Front Door >> Remove/Install Front Door - AR72.10-P-0500LF

Remove/Install Front Door - AR72.10-P-0500LF

Model 217 

Model 222 

except code Z07 (B7 armoring on special protection version) 

Shown on model 222.004 left 

G15380233Courtesy of MERCEDES-BENZ USA
WARNING Risk of injury  caused by fingers being jammed or pinched when removing, installing or aligning hoods, doors, trunk lid/rear-end door or sliding roof. No parts of the body or limbs should be within the operating area when the components are moving. AS00.00-Z-0011-01A
Topical note  Information on preventing damage to electronic components due to electrostatic discharge   AH54.00-P-0001-01A
REMOVINGINSTALLING Remove/install     
1 Completely lower side window (2) on front door (1)    
2 Switch off ignition and remove transmitter key    
3 Disconnect battery ground line   AR54.10-P-0003LF
4 Disconnect left front electrical connector (X35/1) or right front door electrical connector (X35/2)    
5 Remove caps from bolts (3)    
6 Remove bolts (3) INSTALLATION IMPORTANT : Moisten thread on bolts (3) with Loctite. Repair paint damage in area of bolts (3).  
    TORQUE SPECIFICATION Model 217 Bolt, hinge shaft *BA72.10-P-1003-01X 
    TORQUE SPECIFICATION Model 222
except code Z07 (B7 armoring on special protection version) Bolt to hinge shaft
*BA72.10-P-1003-01V 
    Thread locking agent, Loctite 243 (10 ml) *BR00.45-Z-1133-02A 
7 Mask front fender (4) and front door (1) as shown with adhesive tape (5)    
8 Remove front door (1) from hinges and lay on a suitable base NOTES
Carefully remove front door (1).
If the front door (1) comes into contact with the vehicle, the paint can be damaged.
IMPORTANT Helper required.
 
9 Install in the reverse order    
10 Check gap dimensions on front door (1), correct if necessary   AR72.10-P-0550LF 
11 Check for proper function and synchronize power window IMPORTANT Actuate button to close side window and hold for approx. 5 s. Then check whether side window opens or closes correctly.  
FRONT DOOR

Number Designation MODEL 222 except CODE Z07
BA72.10-P-1003-01V Bolt to hinge shaft Nm 34
FRONT DOOR

Number Designation Model 217
BA72.10-P-1003-01X Bolt, hinge shaft Nm 34
REPAIR MATERIALS

Number Designation Order number
BR00.45-Z-1133-02A Thread locking agent, Loctite 243 (10 ml) A 613 989 09 71 09