Disconnect/Connect Battery Ground Line - AR54.10-P-0003LF
Model 217, 222
Show on model 222.004
| Risk of fire /risk of explosion due to short circuit and escaping oxyhydrogen gas. Risk of (burn) injury caused by caustic burns to eyes, skin and mucous membranes from battery electrolyte/mist, short circuit and arcing. Risk of poisoning caused by swallowing battery electrolyte or absorption of lead through the skin or body orifices. Risk of death due to voltage U >= 30 V AC and U >= 60 V DC. | No fires, sparks, open flames, or smoking. Wear acid-resistant gloves, clothing, and glasses. Pour battery acid only into suitable and appropriately marked containers. |
AS54.10-Z-0001-01A | |
| Risk of injury. Moving parts can pinch, crush or, in extreme cases even sever extremities. | No parts of the body or limbs should be within the operating area of mechanical components when moving components. | AS00.00-Z-0009-01A | |
| Topical note | General information on handling vehicles with high-voltage on-board electrical system and/or lithium-ion battery and/or gaseous-fuel drive system | AH00.00-Z-0300-01A | |
| Topical note | Notes on battery | AH54.10-P-0001-01A | |
| Notes on HANDS-FREE ACCESS | AH80.61-P-0001-01A | ||
| Remove/install | |||
| 1 | Switch off all electrical consumers, and disconnect charger and vehicle diagnosis system. | If electrical consumers are active, a charger or a vehicle diagnosis system is connected. | |
Risk of damage to consumers when disconnecting/connecting ground line. |
AD00.00-P-2000-04B | ||
| 2 | Switch off ignition and store transmitter key outside of transmitter range (min. 2 m). | ||
| 3 | Open hood. | Model 222.004/057/104/157/163/173 This ensures that no currents are flowing in the 12 V on-board electrical system. |
|
| 4.1 | Remove load compartment well. | Model 222 | AR68.30-P-4600LF |
| 4.2 | Remove front partition trim or trunk lining. | Model 217 | |
| Model 217.4 | AR68.30-P-4602LCA | ||
| Model 217.3 | AR68.30-P-4600LC | ||
| 5 | Disconnect ground cable. | Model 217.4 | AR54.10-P-0003-04LCA |
| Model 222.004/057/077/104/157/177/178/179/187/188 Model 222.058/059/060/158/159/160/169/969 Model 222.083/086/183/186/983/986 except code 811 (High-End sound system) Model 222.176 except code Z07 (B7 armoring on special protection version) |
AR54.10-P-0003-04LF | ||
| Model 217.3 Model 222.020/021/032/033/034/035/064/066/067/082/085/120/121/123/132/133/134/135/150/155/162/163/164/165/166/167/173/182/184/185 Model 222.083/086/183/186/983/986 with code 811 (High-End sound system) Model 222.176 with code Z07 (B7 armoring on special protection version) Model 222.964/967/976/980/982/984/985 |
AR54.10-P-0003-04LFA | ||
| *BA54.10-P-1003-01J | |||
| *BA00.19-P-1012-01C | |||
| *BA00.19-P-1012-01J | |||
| 6 | Slide cover (5) to the side and remove cover above coolant expansion reservoir. | Model 222.004/057/104/157/163/173 | |
| 7 | Test voltage. | Model 217.364/382/384/385 Model 222 (except 222.077/176/177/178/179/187/188/980) except code B01 (48V technology) |
|
| Model 222.004/057/104/157/163/173 except code B01 (48V technology) |
AR54.10-P-0003-05LFA | ||
| Model 217.364/382/384/385 Model 222 (except 222.004/057/077/083/086/104/157/163/173/176/177/178/179/183/186/187/188/980/983/986) except code B01 (48V technology) except code Z07 (B7 armoring on special protection version) |
AR54.10-P-0003-05LF | ||
| 8 | Install in the reverse order |
GROUND POINTS
| Number | Designation | Model 222 up to model year 2018 | Model 222 as of model year 2018 | ||
|---|---|---|---|---|---|
| BA00.19-P-1012-01C | Battery ground point | W10 | Nm | 16 | 16 |
GROUND POINTS
| Number | Designation | Model 217 up to model year 2018 | Model 217 as of model year 2018 | |||
|---|---|---|---|---|---|---|
| BA00.19-P-1012-01J | Ground point (starter battery) | W10 | Nut (aluminum) | Nm | 7 | 7 |
| Bolt (steel) | Nm | 16 | 16 | |||
BATTERY
| Number | Designation | Model 217 | Model 222 | |
|---|---|---|---|---|
| BA54.10-P-1003-01J | Nut, charging cable to negative terminal/positive terminal of on-board electrical system battery | Nm | 6 | 6 |