Service Sheet for Mercedes-Benz Maintenance System (USA) - AP00.20-U-1208DJ

WARNING: This page does not describe the selected car, but rather 203 other vehicles, including the 2020 Mercedes-Benz SLC300, 2020 Mercedes-Benz SL550, 2020 Mercedes-Benz SL450, 2020 Mercedes-Benz S65 AMG, and 2020 Mercedes-Benz GLA250. However, it is still accessible from the selected car via links, so may be relevant.

MODEL 212.004/059/076/088/091/092/095/097/276/288 as of model year 2014 up to model year 2015

MODIFICATION NOTES

2.6.14	P-2374-212-14C (06/14)	Transmission fluid change revised
12.3.14	P-2374-212-14B (05/14)	References updated
22.2.13	P-2374-212-14A (03/13)	Initial version

Fig 1: Mercedes-Benz Maintenance System Work Sheet (USA)

Courtesy of MERCEDES-BENZ USA

A	B		Input condition not OK:	ⓧ
Completed

		Required Service Work
□	□	Reset maintenance service indicator in instrument	----------	□
					AP00.20-P-0042EW
□	□	Engine - oil and filter change	----------	□
			engine 157		AP18.00-P-0101EWG
			engine 276		AP18.00-P-0101CWZ
			engine 278		AP18.00-P-0101EW
			engine 651		AP18.00-P-0101CWA
□	□	Check catch, safety catch and hinges on engine hood for proper operation	----------	◦
					AP88.40-P-8851EW
	□	Check condition of poly-V-belt	----------	◦
					AP13.22-P-1352EW
□	□	Clean visible area of water deflector	----------	□
					AP82.35-P-8232A
□	□	Fill up with DEF	----------	□
			engine 651 with CODE U42 (BlueTEC diesel exhaust treatment (SCR))
					AP14.40-P-1410BT
				fill, subject to a separate invoice
□	□	Check starter using STAR DIAGNOSIS tester	----------	◦
			E400 HYBRID only
					AP15.30-P-1550AA
	□	Replace brake fluid	----------	□
					AP42.00-P-4280EW
	□	Replace combination or dust filter	----------	□
					AP83.00-P-8384EW
□	□	Check thickness of brake pads, front and rear	----------	◦
					AP42.10-P-4253A
□	□	Correct tire inflation pressure including spare (where applicable) and enter in the table at the end of the service sheet	----------	□
					AP40.15-P-4061A
	□	Leakage - major components - check underbody and engine compartment for chafe marks, line routing, damaged components	----------	◦
					AP00.20-P-0053EW
	□	Check DEF lines and components for leaks and damage	----------	◦
			engine 651 with CODE U42 (BlueTEC diesel exhaust treatment (SCR))		AP00.20-P-0053EW
	□	Visually inspect condition of front axle ball joints, rubber boots	----------	◦
					AP33.20-P-3353EW
	□	Visually inspect condition of driveshaft flexible discs	----------	◦
					AP41.10-P-4152EW
	□	Visually inspect condition of steering mechanical components, rubber boots	----------	◦
					AP46.00-P-4653EW
□	□	Coolant - check fluid level and correct if necessary	----------	◦
			refer to AH20.00-P-1142-01CW observe correct coolant composition
□	□	Brake system - check fluid level and correct if necessary	----------	◦
					AP42.10-P-4210EW
□	□	Windshield washer system - check fluid level and correct if necessary	----------	◦
					AP82.35-P-8210EW
	□	Parking brake (function test only)	----------	◦
					AP42.00-P-4290BA
□	□	Reset maintenance service indicator in instrument cluster	----------	□
					AP00.20-P-0042EW
			reminder - if not yet performed
		Recommended Service Work
□		Replace combination or dust filter	----------	□
					AP83.00-P-8384EW
□	□	Replace wiper blades	----------	□
□	□	Horn - Electrical system check	----------	◦
□	□	Warning/indicator lamps - Electrical system check	----------	◦
					AP54.30-P-5451EW
□	□	Illumination and interior lighting/exterior lighting - Electrical system check	----------	◦
					AP54.30-P-5453EW
□	□	Exterior lighting, high beam flasher, hazard warning flasher, turn signals - Electrical system check	----------	◦
					AP82.10-P-8252EW
□	□	Check trunk/cargo area lighting	----------	◦
	□	Check and correct headlamp setting	----------	◦
					AP82.10-P-8260EW
□	□	Battery (Main/starter/auxiliary) check condition using Midtronics battery tester. Attach Midtronics test report print out here	----------	◦
					AP54.10-U-5453A
	□	Check seat belts and buckles for signs of external damage and proper function	----------	◦
					AP91.40-P-9150EW
□	□	Check windshield washer and headlamp cleaning system	----------	◦
					AP82.30-P-8252EW
	□	Check, clean, and lubricate tilt/sliding roof mechanism	----------	◦
			where applicable
	□	Check, clean, and lubricate panoramic roof mechanism	----------	◦
			with CODE 413 (panoramic sliding sunroof)
					AP77.20-P-7732EW
	□	Check bodywork for paintwork damage	----------	◦
					AP98.00-P-9850EW
□	□	Tire rotation	----------	□
			where applicable
□	□	Inspect tires for damage, measure thread depth and enter table at the end of the service sheet	----------	◦
					AP40.10-P-4051EW
□	□	Check TIREFIT tire sealant expiration date	----------	◦
			where applicable
					AP40.10-P-4054R
□	□	Activate Tire Pressure Monitoring System	----------	□
			refer to vehicle Operator's Manual
□	□	Visually check brake system components, lines, hoses, calipers	----------	◦
□	□	Check thickness of brake pads and discs, front and rear wheels removed	----------	◦
			pads		AP42.10-P-4253A
			discs - except CODE B07 (AMG high-performance ceramic composite braking system)		AP42.10-P-4258EW
			discs - with CODE B07 (AMG high-performance ceramic composite braking system)		AP42.10-P-4258QQ
	□	Check chassis and load-bearing body components for damage and corrosion	----------	◦
					AP00.20-P-0090EW
		Required Additional Work At 2, 000 miles, then if more than 40, 000 mi or 4 years since last replacement
		Rear axle differential fluid replacement	----------	□
			CODE 471 (manual locking differential)
					AP35.00-P-3501CMG
		If more than 40, 000 mi or 4 years since last replacement
		Replace fuel filter	----------	□
			engine 651
					AP47.20-P-0780EWD
		Automatic transmission - oil and filter change	----------	□
			engine 157 with NAG2-V Sport and wet startup clutch		AP27.00-P-2702W
		Replace air filter	----------	□
			engine 276		AP09.10-P-0980MM
			engine 157, 278		AP09.10-P-0980AB
			engine 651		AP09.10-P-0980EWD
		If more than 60, 000 mi or 6 years since last replacement
		Automatic transmission - oil and filter change	----------	□
			engine 276 in model E400 HYBRID (transmission 724.2)
					AP27.00-P-2702A
		Replace spark plugs	----------	□
			engine 157, 276, 278
					AP15.10-P-1580EW
		If more than 70, 000 mi or 7 years since last replacement
		Automatic transmission - oil and filter change	----------	□
			engine 276, 278, 651 with NAG2-FE+ (transmission 722.9) except for E400 HYBRID
					AP27.00-P-2702W
		If more than 150, 000 mi or 15 years since last replacement
		Replace fuel filter	----------	□
			engine 157, 276, 278
					AP47.20-P-0780EW
		Replace coolant	----------	□
					AP20.00-P-2080EW
			observe correct coolant composition

Tire inflation pressure (bar/psi)
LF	RF	LR	RR	Spare

Tire thread depth (mm)
	LF	RF	LR	RR
outside
center
inside