LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2010 >> CLS550 >> Repair and Diagnosis >> Suspension >> Rear Suspension >> Suspension - 219 Chassis >> Testing & Repair >> Remove/install rear shock absorber >> Remove/install rear shock absorber - AR32.25-P-0110TY

Remove/install rear shock absorber - AR32.25-P-0110TY

MODEL 219.3 with CODE (489) Aromatic (semi-active air suspension) 

Fig 1: Identifying Rear Shock Absorber Remove/Install Components (1 Of 2)
G10767733Courtesy of MERCEDES-BENZ USA
Fig 2: Identifying Rear Shock Absorber Remove/Install Components (2 Of 2)
G10767734Courtesy of MERCEDES-BENZ USA
REMOVINGINSTALLING Remove/install     
DANGER Risk of injury caused by moving parts that can pinch, crush or,  in extreme cases even sever extremities. Keep body parts and limbs well clear of moving parts. AS00.00-Z-0009-01A
NOTES Notes on self-locking nuts and bolts   AH00.00-N-0001-01A
NOTES While working on the rear axle, care must be taken to ensure that the surface of aluminum components do not get any scratches, cracks and notches. Otherwise the service life of the parts will be affected    
INSTALLATION IMPORTANT Tighten nuts and bolts of chassis components only when vehicle is in the ready-to-drive condition.    
1 Remove left panel (1a) or right panel (1b) in luggage compartment   AR68.30-P-4800TX
2 Remove rear wheel    
REFER TO MAINTENANCE Remove and install wheels   AP40.10-P-4050TX
3 Loosen fender liner (1c) in the rear fender; to do this, unscrew nuts (2), remove expansion rivets (3) and remove bolt (4)    
4 Undo fender liner (1c) in rear fender at front and fold backwards NOTES Fold fender liner (1c) toward rear carefully so as to prevent damage (cracks) in fender liner (1c).
IMPORTANT Fold fender liner (1c) toward rear until rear axle multiple circuit junction connector (X62/8) is accessible.
 
5 Detach rear axle multiple circuit junction connector (X62/8) and unclip electrical feed line from brackets   AR32.22-P-1500-01TX
6 Remove cover (72c) from spring control arm (72)    
7 Discharge to residual pressure in air spring (41) using STAR DIAGNOSIS and immediately raise spring control arm (72) roughly 30 mm with transmission jack COMMERCIALLY AVAILABLE TOOLS (5) NOTES The air spring (41) must not be moved into the stretched position or be upset as the air spring (41) will be caused irreparable damage as a result. AR32.22-P-1500-04TX
NOTES Special information on AIRmatic   AH32.22-P-1000-02T
    SPECIAL TOOL Figure
    COMMERCIALLY AVAILABLE TOOLS *WE58.40-Z-1030-11A 
    INSTALLING The filling process of the air spring (41) should be observed otherwise it will be caused irreparable damage, therefore fill the air spring (41) at the design level using STAR DIAGNOSIS. AR32.22-P-1500-03TX
REFER TO SELF-DIAGNOSTIC SYSTEMS Connect STAR DIAGNOSIS and read out fault memory   AD00.00-P-2000-04A
    STAR DIAGNOSIS, diagnosis system *WH58.30-Z-1048-13A 
8 Unscrew nut (75a) IMPORTANT Counterhold piston rod using open wrench.  
TORQUE SPECIFICATION *BA32.25-P-1001-03I 
9 Remove washer (75b) and upper rubber mount (75c)    
10 Remove shock absorber (75) of spring control arm (72), to do so undo nut (75e) and remove bolt (75f) TORQUE SPECIFICATION *BA32.25-P-1002-03I 
11 Slide damper (75) together and remove    
12 Remove lower rubber mount (75d)    
INSPECT Checking     
13 Check upper rubber mount (75c) and lower rubber mount (75d) IMPORTANT Replace cracked, oiled and deformed rubber mounts.  
14 Check shock absorber (75) for damage    
15 Install in the reverse order    
REAR AXLE SHOCK ABSORBER

Number Designation Model 219 AIRMATIC
BA32.25-P-1001-03I Nut for attaching shock absorber to frame floor M10 Nm 20
BA32.25-P-1002-03I Self-locking nut for attaching shock absorber to spring control arm M10 Nm 55
Fig 3: Identifying Wrench Socket (211 589 00 09 00)
G10767735Courtesy of MERCEDES-BENZ USA
COMMERCIALLY AVAILABLE TOOLS

Number Designation
WH58.30-Z-1048-13A STAR DIAGNOSIS, diagnosis system; Compact Passenger Car 6511 1801 00
WORKSHOP EQUIPMENT

WE58.40-Z-1030-11A Transmission jack