LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2009 >> E350 Base >> Repair and Diagnosis >> Body & Frame >> Towing Systems >> Frame, Trailer Operation -- E350 (211.256) >> Retrofitting & Conversion >> Retrofit mechanical swing-away trailer hitch - AN31.10-P-0001TA

Retrofit mechanical swing-away trailer hitch - AN31.10-P-0001TA

MODEL 211.2##/2## (except 211.276/277) 1# 

except CODE (772) AMG styling package - front spoiler, side skirts and rear apron 

except CODE (950) AMG sport package 

Fig 1: Exploded View Of Retrofit Mechanical Swing-Away Trailer Hitch
G07274333Courtesy of MERCEDES-BENZ OF NORTH AMERICA.
Fig 2: Identifying Trailer Connection Unit Operating Unit And Control Unit
G07274334Courtesy of MERCEDES-BENZ OF NORTH AMERICA.
Fig 3: Identifying Shield And Nuts
G07274335Courtesy of MERCEDES-BENZ OF NORTH AMERICA.
REMOVING Remove     
DANGER Risk of death  caused by vehicle slipping or toppling off of the lifting platform. Align vehicle between columns of vehicle lift and position four support plates at vehicle lift support points specified by vehicle manufacturer. AS00.00-Z-0010-01A
DANGER Risk of explosion  caused by oxyhydrogen gas. Risk of poisoning and caustic burns  caused by swallowing battery acid. Risk of injury  caused by burns to skin and eyes from battery acid or when handling damaged lead-acid batteries No fire, sparks, open flames or smoking. Wear acid-resistant gloves, clothing and glasses. Only pour battery acid into suitable and appropriately marked containers. AS54.10-Z-0001-01A
NOTES Notes regarding installation of trailer hitch   AH31.10-P-1000-02TA 
IMPORTANT Notes on EU type approval requirements Applies only to countries within the European Union.
Notes on acceptance of trailer hitch at an authorized test point
  AH31.10-P-1000-03T 
1 Disconnect ground cable from battery   AR54.10-P-0003TA
2 Remove left and right interior trim in side of cargo area   AR68.30-P-1180T
3 Remove trim from spare tire well Vehicles up to 31.5.06 without code (943) Automatically extendable main loading floor AR68.30-P-4620T
    Vehicles as of 1.6.06 without code (943) Automatically extendable main loading floor AR68.30-P-4620TM
    With code (943) Automatically extendable main loading floor AR68.30-P-4620TA
4 Make cutout for operating lever in spare tire well paneling    
5 Loosen SAM control unit with fuse and relay box in trunk and place to one side Vehicles up to 1.6.08 without code (809) Model year 2009 AR54.21-P-1258TA
    Vehicles as of 2.6.08 with code (809) Model year 2009 AR54.21-P-1258TY
6 Remove rear bumper   AR88.20-P-2200TA
7 Unscrew nuts (16)    
8 Remove shield (17) of rear muffler IMPORTANT Shield (17) on rear muffler on left and right.  
9 Replace electric fan IMPORTANT It should be checked in the EPC whether the electric fan fitted corresponding to the vehicle equipment can be used for retrofit of the trailer hitch (AHV). If necessary the electric fan should be removed and replaced by an electric fan which is compatible with the trailer hitch.  
INSTALLING Install     
10 Retrofit detachable mechanical body components   AN31.11-P-8080-05TA 
    TORQUE SPECIFICATION Nut with spring washer, trailer coupling to rear end center assembly *BA31.11-P-1001-01C 
    TORQUE SPECIFICATION Bolt securing trailer hitch to side member reinforcement *BA31.11-P-1002-01C 
    TORQUE SPECIFICATION Bolt, side member reinforcement to side rail *BA31.11-P-1003-01C 
11 Retrofit trailer connection unit control panel (A63/1)   AN31.11-P-8080-06TA 
    TORQUE SPECIFICATION Bolt, release lever to console *BA31.11-P-1005-01C 
12 Retrofit trailer connection unit control panel (N28/1)   AN31.19-P-8080-05TA 
13 Retrofit trailer hitch wiring harness   AN31.19-P-8100-05TA 
14 Install remaining parts IMPORTANT Steps 9 to 1.  
INSPECT Check     
15 Connect STAR DIAGNOSIS    
REFER TO SELF-DIAGNOSTIC SYSTEMS Connect STAR DIAGNOSIS and read out fault memory   AD00.00-P-2000-04A
16 Perform retrofit variant coding IMPORTANT Variant coding for trailer hitch with STAR DIAGNOSIS.  
17 Supplement special equipment on the vehicle data card and in the vehicle data card online IMPORTANT Enter code (550) Trailer hitch. AN00.01-P-1001-01V
18 Close STAR DIAGNOSIS    
REFER TO SELF-DIAGNOSTIC SYSTEMS Connect STAR DIAGNOSIS and read out fault memory   AD00.00-P-2000-04A
19 Perform function check of lighting signals on the trailer hitch socket (13-pin)   AN31.19-P-8100-06T 
TRAILER HITCH MECHANICAL SYSTEM

Number Designation   Model 211 swing-away trailer control unit valve
BA31.11-P-1001-01C Nut with spring washer, trailer coupling to rear center assembly Nm 50
BA31.11-P-1002-01C Bolt, trailer coupling to longitudinal member reinforcement Nm 110
BA31.11-P-1003-01C Bolt, side member reinforcement to frame side member Nm 50
BA31.11-P-1005-01C Bolt, release lever to bracket Nm 9
PARTS ORDERING NOTES

Part no. Designation Quantity
DG 99 (see EPC) Trailer hitch package contents 1