LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2009 >> CLS63 >> Repair and Diagnosis >> Brakes >> Mechanical - Hydraulic >> Brakes - Hydraulic & Mechanical Systems - 219 Chassis >> Testing & Repair >> Remove/install parking brake pedal assembly - AR42.20-P-0510TX

Remove/install parking brake pedal assembly - AR42.20-P-0510TX

MODEL 219 

Fig 1: Identifying Parking Brake Pedal Assembly Remove/Install Components
G10767980Courtesy of MERCEDES-BENZ USA
REMOVINGINSTALLING Remove/install     
NOTES Notes on self-locking nuts and bolts   AH00.00-N-0001-01A
1 Raise vehicle with lifting platform   AR00.60-P-1000TX
2 Remove crossmember (35) TORQUE SPECIFICATION *BA62.30-P-1001-01C 
3 Loosen and move heat shields (105d, 105e) or remove them Depending on accessibility AR49.00-P-1000-01TX
4 Unhook brake cable (85) from cable slack adjuster (91). IMPORTANT To do this, pre-tension automatic cable slack adjuster (91):
↓
 
Preload automatic slack adjuster. AR42.20-P-0520-01TX
INSTALLATION IMPORTANT To attach brake cable (85): ↓  
Pre-tension automatic cable slack adjuster (91) again. AR42.20-P-0520-01TX
INSTALLATION IMPORTANT After attaching brake cable (85): ↓  
Relieve load on automatic slack adjuster. AR42.20-P-0520-02TX
5 Remove left cover below instrument panel   AR68.10-P-1500TX
6 Remove side paneling in left front footwell    
7 Detach front cover (76) of pedal assembly (71)    
8 Unlock and disconnect electrical connector on parking brake indicator switch (S12)    
9 Remove bolt (72) and take off pedal assembly (71). TORQUE SPECIFICATION *BA42.20-P-1001-01G 
10 Remove cover (77) of pedal assembly (71).    
11 Unhook brake cable (85) from tensioning shackle (85a). INSTALLATION IMPORTANT Pay attention to the correct position of the rubber ring (85b) in the tensioning shackle (85a).  
12 Unclip brake cable (85) from pedal assembly (71) SPECIAL TOOL Fig 2
13 Detach unlocking cable (79) from tensioning shackle (79a)    
14 Unclip unlocking cable (79) from pedal assembly (71) with tool for unlocking cable    
REFER TO SHOP-MADE TOOLS Tool for releasing parking brake control cable   WF58.50-P-4220-01A
15 Install in the reverse order    
INSPECT Checking     
16 Check pedal travel at parking brake pedal (75); adjust parking brake if necessary   AR42.20-P-0540TX 
CROSSMEMBER AND FRONT REINFORCEMENT

Number Designation Model 219
BA62.30-P-1001-01C Bolt, crossmember to body Nm 25
PARKING BRAKE

Number Designation Model 219
BA42.20-P-1001-01G Bolt, foot-operated parking brake pedal assembly at front wall pillar Nm 12
Fig 2: Identifying Snap-Release Tool (129 589 11 63 00)
G10767981Courtesy of MERCEDES-BENZ USA