Electrical System - Body - 140 Chassis
- General Information
- Basic Knowledge
- Headlamp range control/adjustment, function - GF82.10-P-0001
- Electrical system - xenon headlamps, location of components - GF82.10-P-0002-01A
- Exterior lighting, function - GF82.10-P-0003A
- Contents - Function description of exterior lighting - GF82.10-P-0999A
- Xenon headlamp, location/function - GF82.10-P-2001A
- Xenon headlamps, design/function - GF82.10-P-2007A
- Headlamp range adjustment axle sensors, location/purpose - GF82.10-P-2100A
- Headlamp range adjustment motors, location/purpose - GF82.10-P-2101A
- Headlamp range adjustment control module, location/purpose - GF82.10-P-2102A
- Xenon headlamp control module, location/task - GF82.10-P-2104A
- Xenon headlamp ignition unit, location/task - GF82.10-P-2105A
- Contents - Function description of exterior lighting, location/purpose/design/function - GF82.10-P-9999B
- Transmitter for emergency alarm remote actuation task - GF82.25-P-4105-01S
- Table of contents, function description of wiper system (WS) - GF82.30-P-0998ZA
- Rain sensor, location/purpose/design/function - GF82.30-P-4103F
- TELE AID location of components - GF82.95-P-0001
- Safety Precautions
- Risk of death, Risk of explosion/Risk of fire, Risk of injury & Risk of poisoning - AS82.10-Z-0001-01A
- Injury hazard from pinching and crushing, in extreme cases extremities can even be cut off when caught in windshield wiper mechanism. - AS82.30-Z-0001-01A
- The demagnetizing coil presents a lethal hazard for persons with active electronic implants (e.g. heart pacemakers). - AS82.85-Z-0001-01A
- Self-Diagnostic System
- Testing & Repair
- Testing and repair work: Passenger cars: Electrical system body - AR82.00-Z-9140AA
- Removing and installing APS radio and navigation operating unit - AR82.61-P-7412B
- Calibrating electronic compass (APS) - AR82.61-P-7451A
- Removing and installing antenna for global positioning system (GPS) on vehicles with APS - AR82.61-P-7474C
- Removing and installing language control module - AR82.70-P-0001A
- Removing and installing language control module switch - AR82.70-P-0002A
- Removing and installing transmitter-receiver unit - AR82.70-P-8911Z
- Removing and installing handset in armrest - AR82.70-P-8913A
- Removing and installing antenna - AR82.70-P-8951
- Removing and installing hands-free system speaker - AR82.70-P-8968A
- Removing and installing hands-free system microphone - AR82.70-P-8969Z
- Demagnetizing the vehicle - AR82.85-P-7392A
- Removing and installing TELE AID emergency call system transmitter/receiver - AR82.95-P-0001A
- Removing and installing TELE AID emergency call system pushbutton switch - AR82.95-P-0002A
- Removing and installing TELE AID emergency call system handset - AR82.95-P-0003A
- Removing and installing TELE AID emergency call system spare antenna - AR82.95-P-0004A
- Removing, installing Tele-Aid emergency call system control module - AR82.95-P-0005A
- Authorization for TELE AID - AR82.95-P-0011
- Authorization for taxi emergency call - AR82.95-P-0012A
- Maintenance
- Check and correct headlamp adjustment - AP82.10-P-8260A
- Checking function of headlamp cleaning system - AP82.15-P-8252BA
- Inspect fluid level of windshield washer system, adjust to correct level - AP82.35-P-8210Z
- Windshield wipers, windshield washer system - operational inspection - AP82.35-P-8252BA
- Checking and correcting the windshield washer fluid level - wh8210pkw0000x(8210)
- Cleaning the telescopic antenna rod - wh8231pkw0000x(8231)
- Checking all the functions of the front and rear lights - wh8251pkw0000x(8251)
- Operational check: Windshield wipers, windshield washer, headlamp cleaning system - wh8252pkw0000x(8252)
- Replacing rubber section of wiper blade - wh8280pkw0000x(8280)
- Retrofitting & Conversion
- Activating unit code for APS - AN82.61-P-1000-01A
- Removal and installation of dome lamp with delay and reading lamp - ra82001400011x(0011)
- Removal and installation of rear make up mirror, rear reading lamp - ra82001400015x(0015)
- Removal and installation of rear make up mirror holding clip - ra82001400016x(0016)
- Removal and installation of backup assist element - ra82001400400x(0400)
- Function of headlamp wash/wipe system - ra82001400540x(0540)
- Function of convenience control (power windows and tilting/sliding roof) - ra82001400605x(0605)
- Removing and installing convenience control module - ra82001400608x(0608)
- Removal and installation of wiper arms - ra82001400610x(0610)
- Removal and installation of wiper blade rubber - ra82001400625x(0625)
- Removal and installation of wiper system - ra82001400640x(0640)
- Removal and installation of wiper motor - ra82001400680x(0680)
- Removal and installation of windshield washer system reservoir - ra82001400700x(0700)
- Removal and installation of wiper linkage - ra82001400760x(0760)
- Removing and installing rain sensor - ra82001400770x(0770)
- Removal and installation of windshield washer nozzles - ra82001400792x(0792)
- Remove and install switches for front and rear power seat adjustment - ra82001400865x(0865)
- Removal and installation of bulb for center high mounted rear stop lamp - ra82001401219x(1219)
- Removing and installing lens of headlamp unit - ra82001401820x(1820)
- Removal and installation of headlamp reflector - ra82001402850x(2850)
- Removal and installation of the fog lamp reflector - ra82001402930x(2930)
- Function of electric headlamp range adjustment - ra82001404080x(4080)
- Removing and installing electric headlamp range adjustment control module for Xenon headlamps - ra82001404081x(4081)
- Removing and installing motor for electric headlamp range adjustment with Xenon headlamps - ra82001404082x(4082)
- Removing and installing front axle sensor for headlamp range adjustment with Xenon headlamps - ra82001404083x(4083)
- Removing and installing rear axle sensor for headlamp range adjustment with Xenon headlamps - ra82001404084x(4084)
- Removing and installing actuator for headlamp unit with standard headlamps - ra82001404301x(4301)
- Function of Xenon headlamp - ra82001404630x(4630)
- Removing and installing control module (Xenon headlamps) - ra82001404631x(4631)
- Removing and installing ignition module (Xenon headlamps) - ra82001404632x(4632)
- Removal and installation of headlamp unit - ra82001404730x(4730)
- Removing and installing taillamp - ra82001404905x(4905)
- Removal and installation of the license plate lamp - ra82001405161x(5161)
- Removal and installation of center high mounted rear stop lamp - ra82001405375x(5375)
- Removal and installation of light strip (reverse lamp) - ra82001405381x(5381)
- Function of light warning buzzer - ra82001405891x(5891)
- Removal and installation of navigation computer with CD-ROM (APS) - ra82001407410x(7410)
- Removing and installing global positioning system (GPS) control module - ra82001407473x(7473)
- Removal and installation of electronic compass (APS) - ra82001407482x(7482)
- Entering wheel/tire combinations (APS) - ra82001407486x(7486)
- Operation of radio - ra82001407500x(7500)
- Removing and installing CD player with changer - ra82001407507x(7507)
- Removal and installation of receiver and amplifier (2nd block) - ra82001407605x(7605)
- Removal and installation of sound system amplifier - ra82001407720x(7720)
- Removal and installation of loudspeakers in instrument panel - ra82001407833x(7833)
- Removal and installation of loudspeakers in the parcel shelf - ra82001407836x(7836)
- Removing and installing loudspeaker in base of mirror - ra82001407842x(7842)
- Removal and installation of front doors speakers - ra82001407845x(7845)
- Removal and installation of rear door speakers - ra82001407874x(7874)
- Removing and installing rear antenna for global positioning system (GPS) - ra82001407978x(7978)
- Removal and installation of the automatic antenna - ra82001408105x(8105)
- Removal and installation of radio antenna in bumper - ra82001408180x(8180)
- Removal and installation of telescope of automatic antenna - ra82001408200x(8200)
- Remove and install RF antenna cable (single module radio sets) - ra82001408221x(8221)
- Removal and installation AM rear window antenna amplifier - ra82001408347x(8347)
- Removal and installation of the FM bumper antenna amplifier - ra82001408352x(8352)
- Removal and installation of telephone antenna in bumper - ra82001408950x(8950)
- Function description: Infrared interior motion sensor - ra82001409800x(9800)
- Removal and installation of the infrared (IR) transmitter and receiver unit, interior motion sensor (A26/4, A26/5) - ra82001409820x(9820)
- Remove and install anti-theft alarm system (ATA) control unit (N26) - ra82001409830x(9830)
- Remove and install infrared interior motion sensor control module (N26/3) - ra82001409840x(9840)
- Technical modifications: Electric system body - ra8200140ta00x
- Removing and installing bulbs in headlamp unit A. Standard headlamps, bulbs for low/high beams and parking lamps - ra820a1401201x(1201)
- Checking pneumatic headlamp range adjustment on standard headlamps A. Checking adjustment range - ra820a1404011x(4011)
- Removing and installing radio - ra820a1407502x(7502)
- Testing sound system - ra820a1407700x(7700)
- Checking pneumatic headlamp range adjustment on standard headlamps - ra820b1404011x(4011)
- Removing and installing radio - ra820b1407502x(7502)
- Testing sound system - ra820b1407700x(7700)
- Removing and installing radio C. Coding radio (4-digit fixed code) - ra820c1407502x(7502)
- Removing and installing bulbs in headlamp unit - ra820d1401201x(1201)
- Removing and installing radio - ra820d1407502x(7502)
- Removing and installing radio - ra820e1407502x(7502)
- Component Modifications
- Forms