Engine Mechanical - Overhaul - SKYACTIV-G - 2.5L

• Electric Variable Valve Timing Motor/Driver Inspection
• Hydraulic Variable Valve Timing Actuator Inspection
• Electric Variable Valve Timing Actuator Inspection
• Oil Control Valve (OCV) Inspection
  • Coil Resistance Inspection
  • Spool Valve Operation Inspection
• Hydraulic Lash Adjuster (HLA) Inspection
• Rocker Arm Inspection
• Engine Overhaul Service Warning
• Engine Stand Mounting/Dismounting
  • Mounting
  • Dismounting
• Timing Chain Disassembly
  • Notes
  • Water Pump Pulley Disassembly Note
  • Crankshaft Pulley Lock Bolt Disassembly Note
  • Oil Pan Disassembly Note
  • Engine Front Cover Disassembly Note
  • Front Oil Seal Disassembly Note
  • Chain Tensioner Disassembly Note
  • Oil Pump Chain Disassembly Note
• Cylinder Head Disassembly (I)
  • Notes
  • Electric Variable Valve Timing Actuator, Hydraulic Variable Valve Timing Actuator Disassembly Note
  • Camshaft Cap Disassembly Note
  • Rocker Arm Disassembly Note
  • HLA Disassembly Note
  • Cylinder Head Disassembly Note
• Cylinder Head Disassembly (II)
  • Notes
  • Valve Keeper Disassembly Note
  • Valve Seal Disassembly Note
• Cylinder Block Disassembly (I)
  • Notes
  • Dual-mass Flywheel (MTX)/Drive Plate (ATX) Installation Bolt Disassembly Note Dual-mass flywheel installation bolt (MTX)
    • Notes
    • Drive plate installation bolt (ATX)
  • Dual-mass Flywheel Disassembly Note (MTX)
  • Rear Oil Seal Disassembly Note
• Cylinder Block Disassembly (II)
  • Notes
  • Pilot Bearing Disassembly Note
  • Connecting Rod Cap Disassembly Note
  • Connecting Rod Bearing Disassembly Note
  • Piston, Connecting Rod Disassembly Note
  • Snap Ring Disassembly Note
  • Lower Cylinder Block Disassembly Note
  • Thrust Bearing And Main Bearing Disassembly Note
  • Crankshaft Disassembly Note
• Cylinder Head Inspection
• Valve Seat Inspection/Repair
• Valve, Valve Guide Inspection
• Valve Guide Replacement
  • Removal
  • Installation
• Valve Spring Inspection
• Camshaft Inspection
• Cylinder Block Inspection
• Oil Jet Valve Inspection
• Piston Inspection
• Piston Ring Inspection
• Piston Pin Inspection
• Piston And Connecting Rod Inspection
• Connecting Rod Inspection
• Connecting Rod Clearance Inspection
• Crankshaft Inspection
• Dual-Mass Flywheel Inspection
  • Notes
  • Inspection Before Removal
  • Inspection After Removal
• Pilot Bearing Inspection
• Bolt Inspection
• Cylinder Block Assembly (I)
  • Notes
  • Thrust Bearing And Main Bearing Assembly Note
    • Notes
    • Thrust bearing
    • Main bearing
  • Plate Assembly Note
  • Lower Cylinder Block Assembly Note
  • Piston Pin Assembly Note
  • Snap Ring Assembly Note
  • Piston Ring Assembly Note
  • Connecting Rod Bearing Assembly Note
  • Piston, Connecting Rod Assembly Note
  • Connecting Rod Cap Assembly Note
  • Pilot Bearing Assembly Note
• Cylinder Block Assembly (II)
  • Notes
  • Balancer Unit Assembly Note
  • Oil Pump Assembly Note
  • Water Pump Assembly Note
  • Rear Oil Seal Assembly Note
  • End Plate Assembly Note
  • Dual-mass Flywheel (MTX)/Drive Plate (ATX) Installation Bolt Assembly Note
  • Knock Sensor (KS) Assembly Note
• Cylinder Head Assembly (I)
  • Notes
  • Valve Seal Assembly Note
  • Valve Spring Assembly Note
  • Valve Keeper Assembly Note
  • Water Outlet Assembly Note
  • Thermostat Assembly Note
• Cylinder Head Assembly (II)
  • Notes
  • Cylinder Head Assembly Note
  • Water Inlet Pipe Assembly Note
  • HLA Assembly Note
  • Rocker Arm Assembly Note
  • Camshaft Assembly Note
  • Electric Variable Valve Timing Actuator, Hydraulic Variable Valve Timing Actuator Assembly Note
• Timing Chain Assembly
  • Notes
  • Oil Pump Chain Assembly Note
  • Timing Chain Assembly Note
  • Engine Front Cover Assembly Note
  • Oil Pan Assembly Note
  • Electric Variable Valve Timing Motor/Driver Assembly Note
  • Front Oil Seal Assembly Note
  • Crankshaft Pulley Lock Bolt Assembly Note
  • Water Pump Pulley Assembly Note
  • Oil Shower Pipe Assembly Note
  • Cylinder Head Cover Assembly Note
• Engine Technical Data
• Engine SST