LEMON Manuals: Even more car manuals for everyone
Home >> Kia >> 2023 >> Sorento Plug-In Hybrid SX Prestige >> Repair and Diagnosis >> External Pages >> Different car >> Section 52 (Motor Driven Power Steering System Diagnosis (PHEV)) >> DTC C2412-16: Motor Short Or Open >> Component Inspection >> Notes

Component Inspection: Notes

WARNING: This page is about a different car, the 2024 Kia Sorento. However, it is still accessible from the selected car via links, so may be relevant.
  1. Ignition "OFF".
  2. Shift lever position "P" and Ignition "ON".
  3. Connect KDS/GDS and select "Diagnostic Trouble Codes (DTC)" mode.
  4. Using a KDS/GDS, clear DTC.
  5. Operate the vehicle within DTC detecting condition in general information. (turn right and left at least 1 time)
  6. Select "Diagnostic Trouble Codes (DTC)" mode again.
  7. Is the same DTC stored in the system?

    Good 

    • Fault is intermittent caused by poor contact in the sensor's and/or MDPS unit connector or was repaired and MDPS unit memory was not cleared. Thoroughly check connectors for backed out terminal, improper mating, broken locks, looseness, poor connection, bending, corrosion, contamination, deterioration, damage or poor terminal to wire connection. Repair or replace as necessary and Go to "Verification Of Repair " procedure.

    No Good 

    • Carefully re-do this troubleshooting guide steps.
    • If no problems were found with the circuits or connectors, replace the MDPS unit and Go to "Verification Of Repair " procedure.

If necessary, follow the "Vehicle S/W Management" steps after replace the MDPS unit.

scientia non olet · About LEMON Manuals