LEMON Manuals: Even more car manuals for everyone
Home >> Hummer >> 2008 >> H2 4D Utility Wagon >> Repair and Diagnosis >> External Pages >> Different car >> Section 92 (Heating, Ventilation, And Air Conditioning) >> Repair Instructions >> Compressor Replacement >> Installation Procedure

Installation Procedure

WARNING: This page does not describe the selected car, but rather 8 other vehicles, including the 2007 GMC Yukon XL, 2007 GMC Yukon, 2007 Chevrolet Tahoe, 2007 Chevrolet Suburban, and 2007 Chevrolet Avalanche. However, it is still accessible from the selected car via links, so may be relevant.
    Fig 1: View of A/C Compressor & Bolts
    GM648141Courtesy of GENERAL MOTORS CORP.
  1. Install the A/C compressor (2) to the bracket (1) through the fender well. Insert the mounting bolt (3) into the lower right mounting boss before installing the A/C compressor.
  2. Install the A/C compressor to the bracket. Insert the mounting bolt into the lower right mount before installing the A/C compressor.
    3. NOTE: Refer to Fastener Notice .
  3. Install the A/C compressor mounting bolts.

    Tighten:  Tighten the bolts to 50 N.m (37 lb ft).

  4. Connect the electrical connector to the A/C compressor.
  5. Install the A/C discharge hose to the compressor using new sealing washers. Refer to Sealing Washer Replacement .
  6. Install the A/C discharge hose bolt to the A/C compressor.

    Tighten:  Tighten the bolt to 16 N.m (12 lb ft).

  7. Install the A/C suction hose to the compressor using new sealing washers. Refer to Sealing Washer Replacement .
  8. Install the A/C suction hose bolt to the A/C compressor.

    Tighten:  Tighten the bolt to 16 N.m (12 lb ft).

  9. Install the wheel house panel to the vehicle. Refer to Front Wheelhouse Liner Replacement .
  10. Install the right front tire and wheel assembly. Refer to Tire and Wheel Removal and Installation .
  11. Install the A/C drive belt. Refer to Drive Belt Replacement - Air Conditioning for the 4.8L, 5.3L, 6.0L and 6.2L engine.
  12. Evacuate and recharge the A/C system. Refer to Refrigerant Recovery and Recharging .
  13. Leak test the fittings of the component using the J 39400-A  . See Special Tools .
scientia non olet · About LEMON Manuals