LEMON Manuals: Even more car manuals for everyone
Home >> Hummer >> 2008 >> H2 4D Utility Wagon >> Repair and Diagnosis >> External Pages >> Different car >> Section 309 (Heating, Ventilation, And Air Conditioning) >> Diagnostic Information and Procedures >> Noise Diagnosis - Auxiliary Blower Motor

Noise Diagnosis - Auxiliary Blower Motor

WARNING: This page does not describe the selected car, but rather 8 other vehicles, including the 2011 GMC Yukon XL, 2011 GMC Yukon, 2011 Chevrolet Tahoe, 2011 Chevrolet Suburban, and 2011 Chevrolet Avalanche. However, it is still accessible from the selected car via links, so may be relevant.
Noise Diagnosis - Auxiliary Blower Motor

Step Action Yes No
1 Were you sent here from Symptoms or another diagnostic table? Go to Step 2  Go to Symptoms - HVAC Systems - Manual
or
Go to Symptoms - HVAC Systems - Automatic
2
  1. Sit inside the vehicle.
  2. Close the vehicle doors and windows.
  3. Turn ON the ignition, with the engine OFF.
  4. Cycle the auxiliary blower motor through all of the speeds and modes in order to determine where and when the noise occurs.
Is a noise evident during auxiliary blower operation?		 Go to Step 3  Go to Step 10 
3 Does the noise vary with the auxiliary blower speed? Go to Step 4  Go to Step 5 
4 Inspect for excessive vibration at each auxiliary blower motor speed by feeling the auxiliary blower case.
Is excess vibration present?		 Go to Step 5  Go to Step 10 
5
  1. Remove the auxiliary blower motor. Refer to Auxiliary Blower Motor Replacement (Extended Wheelbase) , Auxiliary Blower Motor Replacement (Standard Wheelbase) .
  2. Inspect the auxiliary blower motor for deposits of foreign material.
Did you find foreign material on the auxiliary blower motor?		 Go to Step 7  Go to Step 6 
6 Inspect the auxiliary blower motor for the following conditions:
  • Cracked blades
  • A loose impeller retainer
  • Improper impeller alignment

Did you find any of these conditions?		 Go to Step 8  Go to Step 9 
7 Remove the foreign material.
Is the action complete?		 Go to Step 10  -
8 Replace the auxiliary blower motor. Refer to Auxiliary Blower Motor Replacement (Extended Wheelbase) , Auxiliary Blower Motor Replacement (Standard Wheelbase) .
Is the action complete?		 Go to Step 10  -
9 Install the auxiliary blower motor. Refer to Auxiliary Blower Motor Replacement (Extended Wheelbase) , Auxiliary Blower Motor Replacement (Standard Wheelbase) .
Is the action complete?		 Go to Step 10  -
10 Operate the system in order to verify the repair.
Did you find and correct the condition?		 System OK Go to Step 2 
scientia non olet · About LEMON Manuals