LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2016 >> Terrain SL, Gas >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 3 (Engine Mechanical - 3.6L (LFX) - Repair Instructions - On Vehicle) >> Repair Instructions - On Vehicle >> Oil Pan Replacement >> Installation Procedure

Installation Procedure

WARNING: This page is about a different variant/trim than selected.
  1. Assemble the oil pan. Refer to Oil Pan Assemble .
    2. Fig 1: Guide Pin Set Guides
    GM1306197Courtesy of GENERAL MOTORS COMPANY
  2. Install the 8 mm (0.315 in) guides from the EN-46109  guide pin set into the center oil pan rail bolt hole on each side of the engine block.
    3. Fig 2: Sealant Application Locations On Block Pan Rail And Crankshaft Rear Oil Seal Housing
    GM1306200Courtesy of GENERAL MOTORS COMPANY
  3. Place a 3 mm (0.118 in) bead (1) of RTV sealant, on the block pan rail and the crankshaft rear oil seal housing.
    4. Fig 3: Engine Oil Pan
    GM1829127Courtesy of GENERAL MOTORS COMPANY
  4. Position the oil pan onto the block.
    5. Fig 4: Removing Guides From Engine Block
    GM1829130Courtesy of GENERAL MOTORS COMPANY
  5. Remove the EN-46109  set 8 mm (0.315 in) guides from the engine block.
    6. Fig 5: Engine Oil Pan Bolts
    GM1829119Courtesy of GENERAL MOTORS COMPANY
  6. Loosely install the oil pan bolts.
    7. Fig 6: Engine Oil Pan Bolts - Tightening Sequence
    GM1829133Courtesy of GENERAL MOTORS COMPANY
    CAUTION:

    Refer to Fastener Caution .

  7. Tighten the oil pan bolts in sequence.
    1. The 8 mm bolts (1-11) to 25 N.m (18 lb ft).
    2. The 6 mm bolts (12, 13) to 10 N.m (89 lb in).
  8. Install engine front cover. Refer to Engine Front Cover Replacement .
  9. Reposition the air conditioning (A/C) compressor and install the bolts. Refer to Air Conditioning Compressor Replacement (LFX) .
  10. Install the catalytic converter. Refer to Catalytic Converter Replacement - Left Side (LFX) .
  11. Lower the vehicle. Refer to Lifting and Jacking the Vehicle .
  12. Refill the engine oil. Refer to Engine Oil and Oil Filter Replacement .
scientia non olet · About LEMON Manuals