Other Concerns: External Leaks

WARNING: This page is about a different car, the 2014 Ford F-150. However, it is still accessible from the selected car via links, so may be relevant.

Possible Component		Reference/Action
252 - ROUTINE
Transmission Fluid
	Incorrect level	CHECK the transmission fluid level. ADJUST transmission fluid to correct level. REFER to TRANSMISSION FLUID LEVEL CHECK .
	Transmission case vent - damaged, case porosity	REPAIR as necessary.
	Leakage at gaskets, seals, electrical connector	REFER to LEAKAGE INSPECTION , Fluid Leakage in Torque Converter Area and Leak Check Test with A Black Light. REMOVE all traces of lubricant on exposed surface of the transmission. REPAIR as necessary.
Fluid Cooler Tubes
	Cooler tube fittings	LOCATE leak source. REPAIR as required. REFER to TRANSAXLE/TRANSMISSION COOLING .
	Cooler tube O-rings, cooler tubes	LOCATE leak source. REPAIR as required. REFER to TRANSAXLE/TRANSMISSION COOLING .
Torque Converter
	Torque converter studs	INSTALL a new torque converter. If a new or remanufactured torque converter is installed, use the scan tool and follow the on-screen instructions and perform the Misfire Monitor Neutral Profile Correction procedure.
	Torque converter hub seal	INSTALL a new torque converter hub seal.
	Torque converter weld	INSTALL a new torque converter. If a new or remanufactured torque converter is installed, use the scan tool and follow the on-screen instructions and perform the Misfire Monitor Neutral Profile Correction procedure.
Transmission Case
	Case - leaking	INSTALL a new transmission case. REFER to TRANSMISSION - EARLY BUILD or TRANSMISSION - LATE BUILD .
	Transmission vehicle harness connector	INSTALL a new transmission vehicle harness connector O-ring.
	Transmission fluid fill plug	INSTALL a new transmission fluid fill plug.
	Output shaft seal	INSTALL a new seal. REFER to OUTPUT SHAFT SEAL .
	Manual control lever seal	INSTALL a new seal.
	Transmission fluid pan gasket	INSTALL a new gasket.
Fluid Pump
	Fluid pump O-ring	INSTALL a new O-ring. REFER to PUMP ASSEMBLY .
	Fluid pump seal ring	INSTALL a new seal ring. REFER to PUMP ASSEMBLY .