LEMON Manuals: Even more car manuals for everyone
Home >> Ford >> 2005 >> Escape Hybrid, FWD >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 16 (Automatic Transmission - Cd4E) >> Diagnosis And Testing >> Diagnosis By Symptom >> Diagnostic Routines >> Other Concerns: Transaxle Overheating

Other Concerns: Transaxle Overheating

WARNING: This page is about a different variant/trim than selected.
DIAGNOSTIC ROUTINES - OTHER CONCERNS TRANSAXLE OVERHEATING

Possible Component Reference/Action
257 - ELECTRICAL ROUTINE 
Powertrain Control System   
  • Electrical inputs/outputs, vehicle wiring harnesses, powertrain control module, TCC solenoid, transmission fluid temperature (TFT) sensor, OSS, TSS


DIAGNOSTIC ROUTINES - OTHER CONCERNS TRANSAXLE OVERHEATING

Possible Component Reference/Action
357 - HYDRAULIC/MECHANICAL ROUTINE 
Vehicle Overheating   
  • Engine overheating
Fluid   
  • Incorrect level
  • Adjust to correct level.
  • Condition
  • Inspect fluid level and condition. Refer to PRELIMINARY INSPECTION . If fluid is aerated, check thermal valve and filter seals. Repair as necessary.
Cooler Tubes   
  • Damaged, blocked, reversed
  • Inspect for damage. Repair as necessary.
Intake Cooler   
  • Damaged, blocked, restricted or leaking
  • Inspect for damage. Repair as necessary.
Auxiliary Cooler (If Equipped)   
  • Damaged, blocked, restricted or leaking
  • Inspect for damage or incorrect installation. Repair as necessary.
Main Control   
  • Bolts out of torque specification
  • Adjust bolts to specification.
  • Main regulator valve, bypass clutch control valve, converter regulator valve stuck, damaged, misassembled
  • Inspect for damage. Repair as necessary.
  • Hydraulic passages damaged
  • Inspect for damage. Repair as necessary.
  • Separator plates/gaskets damaged
  • Inspect for damage. Repair as necessary.
Torque Converter Clutch   
  • TCC solenoid not functioning correctly (off)
  • Activate solenoid using the Transmission Tester. Repair as necessary.
  • No Apply
  • Go to Routine 240/340.
Pump Assembly   
  • Gasket damaged
  • Inspect for damage. Repair as necessary.
  • Rear lube passage blocked
  • Inspect for damage. Repair as necessary.
Chain Pan   
  • Missing
  • Inspect for missing pan. Install pan if missing.
Thermostatic Fluid Level Control Valve   
  • Stuck open or damaged
  • Inspect for damage. Repair as necessary.
  • Gasket damaged or missing
  • Inspect for damage. Repair as necessary.
  • Bolt or bracket damaged, missing, or incorrect installed
  • Inspect for damage. Repair as necessary.
Case/Converter Housing/Stator Support   
  • Front lube passage blocked or restricted
scientia non olet · About LEMON Manuals