Diagnostic Test

WARNING: This page is about a different car, the 2011 RAM Cab & Chassis. However, it is still accessible from the selected car via links, so may be relevant.

OTHER DTCS
1. Turn the ignition on, engine not running.
2. With the scan tool, View DTCs.
  Are any of the P202A, P202B, P202C, P205C, P205D, P205E DTCs Active?
  
  Yes
  - Perform the diagnostic procedures for the other active DTCs before proceeding with this test.
  No
  - Go To 2.
CHECK THE ENGINE COOLANT LEVEL
NOTE:
If there are DTCs present for the DEF Tank Temperature Sensor or DEF Engine Coolant Control Valve, perform those diagnostic procedures before continuing with this test procedure.
1. Turn the ignition off.
2. Verify the engine coolant level.
  Is the engine coolant level above the minimum?
  
  Yes
  - Go To 3.
  No
  - Fill the engine coolant to the proper level.
  - Perform the POWERTRAIN VERIFICATION TEST - 6.7L. Refer to POWERTRAIN VERIFICATION TEST - 6.7L .
CHECK FOR RESTRICTED OR LEAKING ENGINE COOLANT LINES/HOSES
1. Visually inspect the engine coolant supply and return lines for signs of a restriction or leaks.
  Were any restrictions or leaks found?
  
  Yes
  - Repair or replace the engine coolant lines in accordance with the service information.
  - Perform the POWERTRAIN VERIFICATION TEST - 6.7L. Refer to POWERTRAIN VERIFICATION TEST - 6.7L .
  No
  - Go To 4.
CHECK FOR RESTRICTED DIESEL EXHAUST FLUID TANK HEATER
1. Remove the coolant lines at the DEF Tank Heater Coil.
2. Blow regulated low pressure shop air through the DEF Tank Heater Coil.
  Were any restrictions found?
  
  Yes
  - Replace the DEF Tank Heater Coil in accordance with the service information. Refer to SENSOR, Diesel Exhaust Fluid Level/Temperature , Removal .
  - Perform the POWERTRAIN VERIFICATION TEST - 6.7L. Refer to POWERTRAIN VERIFICATION TEST - 6.7L .
  No
  - Replace the DEF Engine Coolant Control Valve in accordance with the service information. Refer to VALVE, Diesel Exhaust Fluid Engine Coolant Control , Removal .
  - Perform the POWERTRAIN VERIFICATION TEST - 6.7L. Refer to POWERTRAIN VERIFICATION TEST - 6.7L .