LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2021 >> Trailblazer RS, 4WD >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 5 (Engine Controls And Fuel - 1.0L (L4B L4F L4G LIJ) Or 1.2L (L4H L4K LIF LIH) - Repair Instructions) >> Repair Instructions >> Fuel Tank Filler Pipe Replacement >> Installation Procedure

Installation Procedure

WARNING: This page is about a different variant/trim than selected.
  1. GM5278863Courtesy of GENERAL MOTORS COMPANY

    Fuel Tank Filler Pipe (1) @ Vehicle - Install

  2. GM5278862Courtesy of GENERAL MOTORS COMPANY

    Fuel Tank Vapor Pipe (3) @ Fuel Tank Filler Pipe - Connect - Plastic Collar Quick Connect Fitting Service 

  3. Fuel Tank Filler Hose (2) @ Fuel Tank - Connect
  4. Fuel Tank Filler Hose Clamp (1) @ Fuel Tank Filler Hose - Install
  5. GM5278861Courtesy of GENERAL MOTORS COMPANY
    CAUTION:

    Fastener Caution

    Fuel Tank Filler Pipe Bolt (1) - Install and tighten 9 N.m (80 lb in)

  6. GM5390614Courtesy of GENERAL MOTORS COMPANY

    Fuel Tank Filler Pipe Ground Bolt (1) - Install and tighten 9 N.m (80 lb in)

  7. Rear Wheelhouse Liner- Left Side - Install - Rear Wheelhouse Liner Replacement
  8. Install the left rear tire and wheel assembly. Tire and Wheel Removal and Installation
  9. Lower the vehicle.
  10. Fuel Tank Filler Door Latch Housing - Install - Fuel Tank Filler Door Latch Housing Replacement
  11. Refill the fuel tank.
scientia non olet · About LEMON Manuals