LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2020 >> Malibu LS >> Repair and Diagnosis >> External Pages >> Different car >> Section 17 (Engine Cooling System) >> Repair Instructions >> Radiator Replacement (LKN) >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2019 Chevrolet Malibu. However, it is still accessible from the selected car via links, so may be relevant.
  1. Drain the cooling system. Cooling System Draining and Filling (GE-47716) , or Cooling System Draining and Filling (Static) 
  2. Recover the refrigerant. Refrigerant Recovery and Recharging (R-1234yf)
  3. GM4324192Courtesy of GENERAL MOTORS COMPANY

    Air Conditioning Condenser Bracket (1) - Remove - Air Conditioning Condenser Bracket Replacement (LKN)

  4. Front Bumper Fascia Center Support - Remove - Front Bumper Fascia Center Support Replacement
  5. GM4232323Courtesy of GENERAL MOTORS COMPANY

    Radiator Upper Bracket (3) -Left Side - Remove - Radiator Upper Bracket Replacement - Left Side (Front End Upper Tie Bar) , or Radiator Upper Bracket Replacement - Left Side (Upper Mounting Pin) 

  6. GM4232712Courtesy of GENERAL MOTORS COMPANY

    Radiator Upper Bracket (3) -Right Side - Remove - Radiator Upper Bracket Replacement - Right Side (Front End Upper Tie Bar) , or Radiator Upper Bracket Replacement - Right Side (Upper Mounting Pin) 

  7. GM4322239Courtesy of GENERAL MOTORS COMPANY

    Radiator Inlet Hose (2) @ Radiator Assembly - Remove - Radiator Inlet Hose Replacement (LKN) 

  8. GM4239827Courtesy of GENERAL MOTORS COMPANY

    Disconnect the engine cooling fan harness connectors (1) from the engine harness.

  9. Disconnect the ground wire from the front end upper tie bar.
  10. GM4296770Courtesy of GENERAL MOTORS COMPANY

    Transmission Fluid Cooler Outlet Pipe (1) @ Transmission Fluid Cooler Pipe Clip - Remove - Transmission Fluid Cooler Outlet Pipe Replacement (LKN With MKE)

  11. GM4296772Courtesy of GENERAL MOTORS COMPANY

    Transmission Fluid Cooler Outlet Pipe (2) @ Transmission Cooler Bypass Valve - Remove - Transmission Fluid Cooler Outlet Pipe Replacement (LKN With MKE)

  12. GM4296786Courtesy of GENERAL MOTORS COMPANY

    Transmission Fluid Cooler Inlet Pipe (1) @ Transmission Fluid Cooler Pipe Clip - Remove - Transmission Fluid Cooler Inlet Pipe Replacement (LKN With MKE)

  13. GM4296787Courtesy of GENERAL MOTORS COMPANY

    Transmission Fluid Cooler Inlet Pipe (2) @ Transmission Cooler Bypass Valve - Remove - Transmission Fluid Cooler Inlet Pipe Replacement (LKN With MKE)

  14. GM4322546Courtesy of GENERAL MOTORS COMPANY

    Radiator Outlet Hose (2) @ Radiator Assembly - Remove - Radiator Outlet Hose Replacement (LKN) 

  15. GM4322997Courtesy of GENERAL MOTORS COMPANY

    Generator Control Module Coolant Pipe Clip (3) @ Engine Coolant FanRemove - Drive Motor Generator Control Module Coolant Pump Hose Replacement (Pump to Aux Radiator)

  16. GM4322552Courtesy of GENERAL MOTORS COMPANY

    Engine Coolant Fan Wiring Harness (2) @ Generator Control Module Coolant PumpDisconnect

  17. GM4324250Courtesy of GENERAL MOTORS COMPANY

    Engine Coolant Fan Module Radiator (1) - Remove

  18. GM4324255Courtesy of GENERAL MOTORS COMPANY

    Disconnect the electrical connector.

  19. Engine Coolant Fan Shroud Bolt (1) - Remove [2x]
  20. Engine Coolant Fan (2) @ Radiator Assembly - Remove
  21. GM4296616Courtesy of GENERAL MOTORS COMPANY

    Transmission Cooler Bypass Valve (1) @ Radiator AssemblyRemove

  22. GM4240228Courtesy of GENERAL MOTORS COMPANY

    Radiator Upper Bracket (1) @ Radiator Assembly (3) - Remove

    [2x]

  23. Radiator Lower Bracket (2) @ Radiator Assembly (3) - Remove [2x]
  24. Engine Coolant Temperature Sensor Retainer (5) @ Radiator Assembly (3) - Remove
  25. Engine Coolant Temperature Sensor (4) @ Radiator Assembly (3) - Remove