LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2018 >> Spark LT, Automatic CVT Trans >> Repair and Diagnosis >> External Pages >> Different car >> Section 56 (Automatic Transmission - JATCO CVT) >> Repair Instructions - On Vehicle >> Range Selector Lever Cable Replacement >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2017 Chevrolet Spark. However, it is still accessible from the selected car via links, so may be relevant.
  1. Set the park brake and chock the wheels.
  2. Without draining the coolant or removing the hoses, remove and position aside the radiator surge tank. Refer to Radiator Surge Tank Replacement .
  3. Remove the ECM from the battery tray. Refer to Engine Control Module Replacement .
  4. Position the transmission manual shift lever into the park position.
    Fig 1: Transmission Range Selector Lever Cable Terminal
    GM4112708Courtesy of GENERAL MOTORS COMPANY
  5. Disconnect the transmission range selector lever cable terminal (1) from the transmission range selector lever.
  6. Press the retainer clip tabs inward in order to release the transmission range selector lever cable (2) from the cable bracket.
  7. Remove the transmission range selector lever cable clip nuts (1).
    Fig 2: Transmission Range Selector Lever Cable Clip Nuts
    GM4112720Courtesy of GENERAL MOTORS COMPANY
  8. Remove the transmission range selector lever cable bracket (2) from the underbody.
  9. Remove the front floor console. Refer to Front Floor Console Replacement .
  10. Disconnect the transmission range selector lever cable terminal (2) from the shift lever pin (3).
    Fig 3: Transmission Range Selector Lever Cable Terminal
    GM4112721Courtesy of GENERAL MOTORS COMPANY
  11. Release the transmission range selector lever cable retainer (1) and remove the transmission range selector cable from the transmission control lever base (4).
  12. Remove the transmission range selector lever cable grommet nuts (1).
    Fig 4: Transmission Range Selector Lever Cable Grommet Nuts
    GM4112723Courtesy of GENERAL MOTORS COMPANY
  13. Remove the transmission range selector lever cable grommet (2).
  14. Remove the transmission range selector lever cable from the vehicle.
scientia non olet · About LEMON Manuals