LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2018 >> Equinox L >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 7 (Engine Controls And Fuel - 2.0L (LTG) - Repair Instructions) >> Repair Instructions >> Fuel Tank Replacement (AWD) >> Removal Procedure

Removal Procedure

WARNING: This page is about a different variant/trim than selected.
    WARNING:

    Refer to Diesel/Gasoline Vapors Warning .

    WARNING:

    Refer to Safety Glasses Warning .

  1. Relieve the fuel system pressure. Fuel Pressure Relief 
  2. Drain the fuel tank. Fuel Tank Draining 
  3. Raise and support the vehicle. Lifting and Jacking the Vehicle .
  4. Remove Exhaust Muffler Assembly - Exhaust Muffler Replacement (LTG, LYX)
  5. Remove Driveline Torque Tube - Driveline Torque Tube Replacement
  6. Remove Underbody Rear Air Deflector - Underbody Rear Air Deflector Replacement (All Wheel Drive)Underbody Rear Air Deflector Replacement (Diesel)
    7. Fig 1: Fuel Tank Fuel Pump Module Wiring Harness, Fuel Pump Fuel Feed Hose And Evaporative Emission Canister Vent Hose
    GM4594768Courtesy of GENERAL MOTORS COMPANY
  7. Disconnect Fuel Tank Fuel Pump Module Wiring Harness (1) - [2x]
  8. Remove Fuel Tank Fuel Pump Module Wiring Harness (1) @ Retainer - [2x]
  9. Disconnect Fuel Pump Fuel Feed Hose (3) - Plastic Collar Quick Connect Fitting Service 
  10. Disconnect Evaporative Emission Canister Vent Hose (4) - Plastic Collar Quick Connect Fitting Service 
    11. Fig 2: Fuel Tank Vent Hose, Fuel Tank Filler Hose And Clamp
    GM4594772Courtesy of GENERAL MOTORS COMPANY
  11. Disconnect Fuel Tank Vent Hose (1) - Plastic Collar Quick Connect Fitting Service 
  12. Remove Fuel Tank Filler Hose Clamp (2).
  13. Remove Fuel Tank Filler Hose (3).
    14. Fig 3: Fuel Tank Strap And Bolt
    GM4594775Courtesy of GENERAL MOTORS COMPANY
  14. Place a suitable adjustable jack under the fuel tank.
  15. Remove Fuel Tank Strap Bolt (1) - [5x]
  16. Remove Fuel Tank Strap (2) - [2x]
    17. Fig 4: Fuel Tank
    GM4594779Courtesy of GENERAL MOTORS COMPANY
  17. Remove Fuel Tank (1)
  18. If replacing fuel tank transfer parts as necessary.
scientia non olet · About LEMON Manuals