LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2018 >> Equinox L >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 14 (Engine Controls And Fuel - 1.6L (LH7) Diesel - Repair Instructions) >> Repair Instructions >> Fuel Tank Filler Pipe Replacement >> Removal Procedure

Removal Procedure

WARNING: This page is about a different variant/trim than selected.
    WARNING:

    Refer to Diesel/Gasoline Vapors Warning .

    WARNING:

    Refer to Safety Glasses Warning .

  1. Remove Fuel Tank Filler Pipe Housing. Refer to Fuel Tank Filler Pipe Housing Replacement (Equinox)Fuel Tank Filler Pipe Housing Replacement (Terrain)
  2. Remove Rear Wheelhouse Liner-Left Side. Refer to Rear Wheelhouse Liner Replacement- Left Side (Equinox)Rear Wheelhouse Liner Replacement- Left Side (Terrain)
  3. Drain the fuel tank below the fuel tank filler pipe. Refer to Fuel Tank Draining 
    4. Fig 1: Fuel Tank Filler Pipe Ground Bolt
    GM4693781Courtesy of GENERAL MOTORS COMPANY
  4. Remove Fuel Tank Filler Pipe Ground Bolt (1)
    5. Fig 2: Fuel Tank Filler Pipe Ground Bolts
    GM4693784Courtesy of GENERAL MOTORS COMPANY
  5. Remove Fuel Tank Filler Pipe Ground Bolts (1) (Qty: 2)
    6. Fig 3: Fuel Tank Vent Hose, Fuel Tank Filler Hose And Clamp
    GM4693785Courtesy of GENERAL MOTORS COMPANY
  6. Disconnect Fuel Tank Vent Hose (1). Refer to Plastic Collar Quick Connect Fitting Service 
  7. Remove Fuel Tank Filler Hose Clamp (2)
  8. Remove Fuel Tank Filler Hose (3)
    9. Fig 4: Fuel Tank Filler Pipe
    GM4693786Courtesy of GENERAL MOTORS COMPANY
  9. Remove Fuel Tank Filler Pipe (1)
scientia non olet · About LEMON Manuals