LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2017 >> Spark LT, Automatic CVT Trans >> Repair and Diagnosis >> External Pages >> Different car >> Section 65 (Power Door Lock System And Vehicle Access System) >> Repair Instructions >> Front Side Door Lock Replacement

Front Side Door Lock Replacement

WARNING: This page is about a different car, the 2019 Buick Cascada, 2018 Buick Cascada, and 2017 Buick Cascada. However, it is still accessible from the selected car via links, so may be relevant.
GM2190584
Callout Component Name

Preliminary Procedures

  1. Place the front side door window in the full up position.
  2. Remove the front side door trim. Refer to Front Side Door Trim Replacement .
  3. Remove the water deflector. Refer to Front Side Door Water Deflector Replacement .
  4. Remove the outside door handle. Refer to Front Side Door Outside Handle Replacement .
1 Front Side Door Lock Screw (Qty: 3)
CAUTION:

Refer to Fastener Caution .

Procedure

  1. Remove and DISCARD the screw.
  2. Cut the thread.
NOTE:

Service may offer bolts that are not microencapsulated. If this is the case apply thread lock agent to the bolt.


Tighten 
9 N.m (80 lb in)
2 Front Side Door Lock Assembly

Procedure

  1. Release the door lock cable retainers from the door.
  2. Disconnect the door lock electrical connector.
  3. Remove the door lock with the handle housing.
  4. Remove the handle and lock rods from the lock.
  5. Inspect the lock, lock cylinder and handle adjustments. Refer to Front Side Door Outside Handle Rod Adjustment .
scientia non olet · About LEMON Manuals