LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2015 >> Cruze LT, Automatic Trans >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 8 (Engine Controls And Fuel - 1.8L (LUW, LWE) - Repair Instructions) >> Repair Instructions >> Throttle Body Assembly Replacement >> Removal Procedure

Removal Procedure

WARNING: This page is about a different variant/trim than selected.
  1. Remove the air cleaner outlet duct. Refer to Air Cleaner Outlet Duct Replacement .
  2. Disconnect the wiring harness plug (2).
    Fig 1: Throttle Body Heater Outlet Pipe, Throttle Body Heater Inlet Pipe And Positive Crankcase Ventilation Pipe
    GM2027480Courtesy of GENERAL MOTORS COMPANY
  3. Disconnect the positive crankcase ventilation pipe (1).
  4. Place collecting basin underneath.
  5. Disconnect the throttle body heater outlet pipe (4).
  6. Disconnect the throttle body heater inlet pipe (3).
  7. Remove the 4 throttle body bolts (2).
    Fig 2: Throttle Body
    GM2026836Courtesy of GENERAL MOTORS COMPANY
  8. Remove the throttle body (1).
  9. Remove and DISCARD the throttle body gasket.
scientia non olet · About LEMON Manuals