LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2015 >> Cruze LT, Automatic Trans >> Repair and Diagnosis >> External Pages >> Different car >> Section 52 (Engine Controls And Fuel - 1.4L (LUV) - Repair Instructions) >> Repair Instructions >> Fuel Tank Filler Pipe Replacement >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2015 Chevrolet Trax and 2015 Buick Encore. However, it is still accessible from the selected car via links, so may be relevant.
    Fig 1: Fuel Tank Filler Pipe Quick Connect Fitting
    GM2884056Courtesy of GENERAL MOTORS COMPANY
  1. Install the fuel tank filler pipe (4) to the vehicle.
    2. CAUTION:

    Refer to Fastener Caution .

  2. Install the fuel tank filler pipe fastener (3) and tighten to 9 N.m (80 lb in).
  3. Connect the fuel tank filler pipe quick connect fitting (1). Refer to Plastic Collar Quick Connect Fitting Service .
  4. Install the fuel tank filler pipe clamp (2).
  5. Lower the vehicle.
    6. Fig 2: Fuel Tank Filler Pipe
    GM2884054Courtesy of GENERAL MOTORS COMPANY
  6. Install the fuel tank filler pipe fastener (1) and tighten to 9 N.m (80 lb in).
  7. Install the right rear wheelhouse panel liner. Refer to Rear Wheelhouse Liner Replacement .
  8. Install the right rear tire and wheel assembly. Refer to Tire and Wheel Removal and Installation .
  9. Fill the fuel tank.
  10. Install the fuel cap.
scientia non olet · About LEMON Manuals