LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2013 >> Sonic RS, Standard Trans >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 4 (Engine Controls/Fuel - 1.8L (LUW, LWE) - Repair Instructions) >> Repair Instructions >> Fuel Tank Filler Pipe Replacement (Steel Tank) >> Removal Procedure

Removal Procedure

WARNING: This page is about a different variant/trim than selected.
    Fig 1: Fuel Filler Door Housing Bracket Fastener
    GM2498413Courtesy of GENERAL MOTORS COMPANY
  1. Remove the fuel filler door housing. Refer to Fuel Tank Filler Door Latch Housing Replacement .
  2. Remove the bracket fastener (1).
    3. Fig 2: Fuel Tank Filler Pipe Bracket Fastener, Vent Hose Clamp & Filler Pipe Hose Clamp
    GM2597399Courtesy of GENERAL MOTORS COMPANY
  3. Lift and support the vehicle. Refer to Lifting and Jacking the Vehicle .
  4. Remove the fuel tank filler pipe bracket fastener (1).
  5. Remove the vent hose clamp (2) and vent hose.
  6. Loosen the filler pipe hose clamp (3).
    7. Fig 3: Fuel Tank Filler Pipe
    GM2498418Courtesy of GENERAL MOTORS COMPANY
  7. Remove the fuel tank filler pipe (1).
scientia non olet · About LEMON Manuals