Section 1033 (Transfer Case - Mp 3023/3024-NQH)
WARNING: This page is about a different car, the 2008 GMC Sierra and 2008 Chevrolet Silverado. However, it is still accessible from the selected car via links, so may be relevant.
- Specifications
- Schematic Wiring Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Code Index
- Diagnostic Starting Point - Transfer Case
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- Diagnostic Trouble Code (DTC) List
- DTC B0770
- DTC B0775
- DTC B0780
- DTC B0785
- DTC B0790
- DTC B2725
- DTC C0306
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Diagnostic Aids
- Circuit/System Testing
- Component Testing
- Repair Procedures
- DTC C0321
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Diagnostic Aids
- Circuit/System Testing
- Component Testing
- Repair Procedures
- DTC C0374
- DTC C0379
- DTC C0387
- DTC C0392
- DTC C0396
- DTC C0397
- DTC C0398
- Diagnostic Instructions
- DTC Descriptor
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Procedures
- DTC C0550
- DTC C0569
- DTC C0896
- DTC P2160 or P2161
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Procedures
- Symptoms - Transfer Case
- Front Axle Will Not Engage
- Front Axle Will Not Disengage
- Transfer Case Shift Control Switch Inoperative
- No Correction for Slip in All-Wheel Drive Mode
- Transfer Case Shift Control Switch Indicator Always On - Two or More
- Transfer Case Shift Control Switch Indicator Inoperative - One or More
- Service Indicator Always On
- Transfer Case High/Low Clutch Reset
- Transfer Case Popping Noise
- Transfer Case Whine or Rumble Noise
- Transfer Case Growl or Grinding Noise
- Transfer Case Grating Noise
- Transfer Case Clunk in 2HI Only
- Transfer Case Clunk in 4HI
- Transfer Case Clunk in 4LO
- Transfer Case Clunk during Acceleration and Deceleration
- Transfer Case Shudder or Binding
- Transfer Case Will Not Shift
- Transfer Case Jumps Out of Gear
- Transfer Case Leak Diagnosis
- Repair Instructions - On Vehicle
- Transfer Case Shift Control Switch Replacement (Without SLT)
- Transfer Case Shift Control Switch Replacement (With SLT)
- Transfer Case Shift Control Module Replacement
- Transfer Case Shield Replacement
- Transfer Case Fluid Replacement
- Transfer Case Two/Four Wheel Drive Actuator Position Sensor Replacement
- Transfer Case Two/Four Wheel Drive Actuator Replacement
- Vehicle Speed Sensor Replacement
- Front Output Shaft Seal Replacement
- Rear Output Shaft Seal Replacement
- Transfer Case Rear Extension Bushing Replacement
- Transfer Case Assembly Replacement
- Transfer Case Adapter Replacement
- Input Shaft Seal Replacement
- Repair Instructions - Off Vehicle
- Transfer Case Disassemble
- Transfer Case Holding Fixture Installation
- Access Hole Plugs, Fill and Drain Plug, Vent, 2/4 Wheel Drive Actuator, Actuator Shaft Position Sensor, and Vehicle Speed Sensor Removal
- Rear Output Shaft Seal and Bushing Removal
- Transfer Case Rear Case Half Removal
- Oil Pump Suction Pipe and Actuator Shaft Gear Removal
- Shift Fork Assembly, Drive Chain, and Rear Output Shaft Assembly Removal
- Rear Output Shaft Assembly Disassemble
- Input Shaft and Planetary Assembly Removal
- Front Output Shaft Assembly Removal
- Transfer Case Front Half Cleaning and Inspection
- Transfer Case Rear Half Cleaning and Inspection
- Oil Pump Cleaning and Inspection
- Rear Output Shaft Cleaning and Inspection
- Front Output Shaft and Input Shaft Cleaning and Inspection
- Drive Chain, Drive Sprocket, and Driven Sprocket Cleaning and Inspection
- High/Low Planetary Carrier Cleaning and Inspection
- High/Low Shift Components Cleaning and Inspection
- Two/Four Wheel Drive Shift Components Cleaning and Inspection
- Transfer Case Four Wheel Drive Actuator Lever Shaft Bearing Replacement - Front
- Transfer Case Four Wheel Drive Actuator Lever Shaft Bearing Replacement - Rear
- Input Shaft Pilot Bearing Replacement (Light Duty)
- Input Shaft Pilot Bearing Replacement (Heavy Duty and Super Heavy Duty)
- Front Output Shaft Front and Rear Bearing Replacement
- Front Output Shaft Drive Sprocket Bearing Replacement
- High/Low Shift Fork Replacement
- Transfer Case Assemble
- Input Shaft and Planetary Assembly Installation
- Measuring Clutch Pack Height
- Clutch Assembly Installation
- Measuring/Adjusting Clutch Assembly Height
- Clutch Pressure Plate Installation
- Rear Output Shaft Assembly
- Shift Fork Assembly, and Rear Output Shaft Assembly Installation
- Front Output Shaft Assembly, Drive Chain, Actuator Shaft Gear, and Oil Pump Suction Pipe Installation
- Transfer Case Rear Case Half Installation
- Rear Output Shaft Seal and Bushing Installation
- Access Hole Plugs, Fill and Drain Plug, Vent, 2/4 Wheel Drive Actuator, Actuator Shaft Position Sensor, and Vehicle Speed Sensor Installation
- Input Shaft Seal and Front Output Shaft Seal Installation
- Transfer Case Disassemble
- Description and Operation
- Transfer Case Identification
- Transfer Case Description and Operation
- Notes
- Transfer Case Shift Control Switch
- 2WD Mode Power Flow
- 4HI Mode Power Flow
- 4LO Mode Power Flow
- NEUTRAL Mode Power Flow
- Service 4WD Indicator
- Transfer Case Two/Four Wheel Drive Incremental Sensor
- Transfer Case Two/Four Wheel Drive Actuator Assembly
- Transfer Case Actuator Shaft Position Sensor Assembly
- Transfer Case Motor Lock
- Transfer Case Shift Control Module
- Vehicle Speed Sensor (VSS)
- Special Tools and Equipment