LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Blazer 4D Utility, 4WD, Part Time >> Repair and Diagnosis >> External Pages >> Different car >> Section 1887 (Heating, Ventilation, And Air Conditioning) >> Repair Instructions >> Condenser Replacement >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2007 Saturn Vue. However, it is still accessible from the selected car via links, so may be relevant.
  1. Recover the refrigerant. Refer to Refrigerant Recovery and Recharging .
  2. Remove the front fascia. Refer to Front Bumper Fascia Replacement (Redline) or Front Bumper Fascia Replacement (Standard) .
    3. Fig 1: View Of Battery Box Inlet Air Duct
    GM948926Courtesy of GENERAL MOTORS CORP.
  3. For L61 vehicles, remove the battery box air duct.
    4. Fig 2: View Of CRFM Closeout/Splash Panel To Condenser
    GM948958Courtesy of GENERAL MOTORS CORP.
  4. Remove the condenser radiator fan module (CRFM) closeout panel.
    5. Fig 3: Receiver Dehydrator, Protective Caps & Liquid Line
    GM932369Courtesy of GENERAL MOTORS CORP.
  5. Remove receiver dehydrator from the condenser.
  6. Install a protective cap to the receiver dehydrator to prevent contamination and desiccant saturation.
    7. Fig 4: Compressor Hose, Nut, Condenser & Protective Cap
    GM932379Courtesy of GENERAL MOTORS CORP.
  7. Remove the compressor hose from the condenser.
  8. Install a protective cap to the compressor hose to prevent contamination and desiccant saturation.
  9. Lift the condenser while holding the upper retention tabs forward.
  10. Remove the condenser from the vehicle.
scientia non olet · About LEMON Manuals