Install the rear window
NOTE:
TECHNICAL INFORMATION
Protect components against corrosion. Treat paint damage with corrosion protection.
Protect components against corrosion. Treat paint damage with corrosion protection.
- Remove the adhesive bead (1) on the body using special tool 0 410 436 .
- Clean the bonding surfaces on the body and the rear window.
- Fasten the cable on the rear window with adhesive tape.
CONSUMABLE SPECIFICATION
| Plastic adhesive tape | 83195B3DD17 |
- Provide two glue cartridges.
- Prepare a glue cartridge with standard nozzle C.
- Apply bead joint in area (1) .
- Apply adhesive bead (2) within the mark on the rear window.
TECHNICAL DATA SPECIFICATION
| Adhesive bead | ||
|---|---|---|
| a = Position of adhesive bead to the tolerance band | 0.5 mm... 1.5 mm | |
| b = Width | 7 mm... 9 mm | |
| h = Height | 11 mm... 13 mm | |
- Detach the liner (protective film) from the adhesive strips (3) .
- Open trunk lid approx. 1/3 and secure in this position.
- Carefully guide rear window (1) with the suction lifters parallel to the C-pillar and feed it in under the tailgate.
- Carefully position rear window (1) with the suction lifters at the top and align it evenly at the sides.
- Carefully push up the rear window (1) with the suction lifters upwards until the seal rests evenly on the roof.
- Carefully and evenly press down the rear window 1 with the suction lifters all around and adjust the gap dimensions.
TECHNICAL DATA SPECIFICATION
| Gap between roof outer skin and glass roof | ||
|---|---|---|
| 1 rear window; 2 roof outer skin | a | 3.2 +1.3-1.3 mm |
| b | 1.1 +1-1.5 mm | |
- Measure the recessed (b)
of the rear window (1)
to the roof outer skin (2)
with the special tool 0 495 259 (51 0 010)
.
Measure gap dimension (a) with the special tool 0 496 076 (00 9 470) .
- Secure rear window (1) with adhesive tap on the roof.
CONSUMABLE SPECIFICATION
| Plastic adhesive tape | 83195B3DD17 |
- Connect plug (1) .
NOTE:
Perform the steps on the right and left side.
- Connect connectors (1) and lock.
Follow-up work
- Refer to INSTALLING THE TRIM PANEL FOR THE STORAGE SHELF .
- Refer to INSTALLING THE C-PILLAR TRIM PANEL ON THE LEFT AND RIGHT .
- Refer to INSTALLING THE LEFT AND RIGHT SEAT BELT FINISHER STRIP .
- Refer to INSTALLING BOTH BACKREST SIDE SECTIONS .
- Refer to 3. INSTALLING THE BRAKE LIGHT .