32 31 595 Dismantling And Assembling Complete Steering Column
Special tools required:
- 00 5 500
- 32 1 090
- 32 1 150
- 32 1 200
- 32 1 204
- 32 3 070
Necessary preliminary tasks:
- Remove steering column, refer to 32 31 090 REMOVING AND INSTALLING COMPLETE STEERING COLUMN
- Remove ring antenna
After installation:
- Turn steering wheel left and right to full lock. The airbag warning lamp must not light up in the process.
- Carry out steering angle sensor adjustment, refer to 61 31 996 CARRY OUT STEERING ANGLE SENSOR ADJUSTMENT
Release screw.
Remove damper.
Remove locking paint.
Release both headless screws and remove ignition starter switch.
Installation:
Secure headless screws with locking paint.
Lift out snap ring (1) and take off with sleeve (2).
installation:
Fit bush (2).
Install snap ring (1) with special tool 32 1 090 / 32 3 070 and steering wheel screw until it snaps into place in groove of steering spindle.
Lift out steering spindle bearing.
Take out bearing inner sleeve.
Installation:
Insert bearing inner sleeve with bevelled end pointing to steering lock.
Unfasten shear-off screws with tool, e.g. chisel.
Installation:
Tighten shear-off screws until heads shear off.
Remove lock cylinder. Refer to 32 32 050 REMOVING AND INSTALLING OR REPLACING STEERING-LOCK CYLINDER .
Detach steering angle sensor (1) from steering spindle.
Installation:
Pin for pivot mounting (2) must engage in steering angle sensor (1).
Lift out snap ring (1).
Remove collar ring (2) and spring (3).
Remove steering spindle and pull out steering column tube.
Installation:
Fit spring (3) and collar ring (2).
Recess in collar ring must point to snap ring (1).
Install snap ring (1) with special tool 32 3 070.
Knock lower steering-spindle bearing out of outer tube.
Installation:
Press contact ring out of new bearing.
Drive in new bearing (1) with special tools 32 1 150 and 00 5 500.
Unfasten screws.
Twist connector to remove from bracket.
Remove gearbox motor.
Remove shaft.
Disconnect torsion spring (8) on both sides.
Unscrew nut (1).
Remove axial grooved ball bearing (2) and clamping disc (3).
Remove retainer (4).
Press clamping fixture (9) out of adjusting lever (5) with special tools 32 1 200 and 32 1 204.
Grip drive of special tool with open-end wrench.
Press clamping fixture (9) into adjusting lever (5) with special tool 32 1 200.
Adjusting lever points towards steering lock and square section on clamping fixture must be inserted in long slot in steering column tube.
Fit retainer (4), clamping disc (3) and axial grooved ball bearing (2). Connect torsion spring (8) on both sides.
Replace nut (1) and tighten. Tightening torque 32 31 3AZ. Refer to STEERING AND WHEEL ALIGNMENT - TIGHTENING TORQUES .