LEMON Manuals: Even more car manuals for everyone
Home >> Audi >> 2016 >> S5 Prestige, 2D Convertible >> Repair and Diagnosis >> External Pages >> Different car >> Section 924 (Suspension System (Front - Service Information)) >> Front Suspension >> SUBFRAME >> SUBFRAME With Steering Gear, Removing And Installing >> Removing

SUBFRAME With Steering Gear, Removing And Installing: Removing

WARNING: This page does not describe the selected car, but rather 9 other vehicles, including the 2018 Audi S6, 2018 Audi A6 Quattro, 2018 Audi A6, 2017 Audi S6, and 2017 Audi A6 Quattro. However, it is still accessible from the selected car via links, so may be relevant.

-- Before starting the procedure, measure the distance from the center of the wheel to the lower edge of the wheel housing. Refer to WHEEL BEARING IN CONTROL POSITION, LIFTING VEHICLES WITH AIR SUSPENSION or WHEEL BEARING IN CURB WEIGHT, LIFTING VEHICLES WITH COIL SPRING .

-- Place the vehicle on a hoist. Refer to RAISING AND LOWERING WITH OPEN AND CLOSED AIR SUSPENSION SYSTEM .

-- For vehicles with an air suspension system, bleed the air suspension system. Refer to SYSTEM, VENTING OR FILLING .

-- Remove the engine cover.

-- Support the engine completely using the :10-222A  . Refer to ENGINE, SUPPORTING IN INSTALLED POSITION [For engine(s) CREC, REH] or ENGINE, SUPPORTING IN INSTALLED POSITION [For engine(s) CTGE, EUC] or ENGINE, SUPPORTING IN INSTALLED POSITION [For engine(s) CPNB] .

-- Remove the front wheels.

-- Remove the noise insulation -1 and 2-. Refer to NOISE INSULATION .

GWWA10-11234Courtesy of AUDI OF AMERICA, LLC

-- Remove the left and right front wheel housing liners. Refer to WHEEL HOUSING LINER .

GWWA66-10868Courtesy of AUDI OF AMERICA, LLC

-- Remove the nuts -3- and remove the cover -2- (if equipped) from the right and left drive axle.

GWWA40-10558Courtesy of AUDI OF AMERICA, LLC

-- Tip the top of the cover -2- toward the outside and guide it downward by the seam -1-.

-- Remove the left and right wheel spoiler. Refer to WHEEL HOUSING LINER .

GWWA66-10793Courtesy of AUDI OF AMERICA, LLC

-- Disconnect the left and right connector -1- from the vehicle level sensor (if equipped) and remove the clip -arrow-.

GWWA10-11376Courtesy of AUDI OF AMERICA, LLC

-- Remove the right and left clamps for the vehicle level sensor wires from the subframe.

-- Free up the electrical wire.

-- Remove the connector -1- for the vehicle signals (CAN bus and terminal 15) from the Power Steering Control Module -J500-.

GWWA48-10592Courtesy of AUDI OF AMERICA, LLC

-- Release the safety mechanism in direction of -arrow-, push the retainer downward and disconnect the connector -2- for the voltage (terminal 30) from the Power Steering Control Module -J500-.

-- Free up the clip -arrow-, disconnect the connector -1- and free up the electric wire.

GWWA40-10565Courtesy of AUDI OF AMERICA, LLC

-- If installed, remove the remaining clips -arrows- on the crossbrace and free up the wiring harness.

GWWA40-10625Courtesy of AUDI OF AMERICA, LLC
NOTE:

Ignore Items -1 through 5-.

-- If installed, open the clip -arrow- on the left rear subframe and free up the wiring harness.

GWWA40-10569Courtesy of AUDI OF AMERICA, LLC

-- Turn the steering wheel so that the wheels are in the straight-ahead position and then tape it secure -arrow- so that it cannot turn.

GWWA48-10744Courtesy of AUDI OF AMERICA, LLC
NOTE:

Be sure to use tape that will not leave behind any residue when it is removed.

Be careful not to turn the steering wheel during the repair because the Airbag Spiral Spring/Return Spring with Slip Ring -F138- can become damaged.

-- Remove the bolt -arrow-.

GWWA40-10551Courtesy of AUDI OF AMERICA, LLC

-- Remove the universal joint -1- from the steering gear -2- and support the steering intermediate shaft so that it cannot fall.

-- Remove the right and left nuts -1- and bolts -2- and remove the heat shield upper section -3-.

GWWA40-10550Courtesy of AUDI OF AMERICA, LLC

-- If equipped remove the Transmission Fluid Cooling Valve -N509-. Refer to COOLANT VALVES, REMOVING AND INSTALLING [For engine(s) CYNB] or COOLANT VALVE, REMOVING AND INSTALLING [For engine(s) CTGE, EUC] or COOLANT VALVE, REMOVING AND INSTALLING [For engine(s) CPNB] or COOLANT VALVE, REMOVING AND INSTALLING [For engine(s) CREC, REH] or COOLANT VALVES, REMOVING AND INSTALLING [For transmission(s) 0B5, CK] [For engine(s) CYNB] .

-- For vehicles with an intermediate flange -1-, remove the bolts -2 and 3- and free up the intermediate flange with the hoses still connected.

GWWA40-10617Courtesy of AUDI OF AMERICA, LLC

-- Tie up the left and right wheel bearing housings using the :T10083  -1-, as illustrated.

GWWA40-10386Courtesy of AUDI OF AMERICA, LLC
NOTE:

To prevent the joints on the upper control arm from being damaged, support the wheel bearing housing.

-- Remove the left and right control arms. Refer to CONTROL ARM, REMOVING AND INSTALLING .

-- Remove the nut from the left and right guide link joint pins enough so it is flush with the joint pin threads. Counterhold the joint pins if necessary.

GWWA40-10214Courtesy of AUDI OF AMERICA, LLC

-- Press the guide link joint pin off the conical seat using the :T40042  .

NOTE:

Be careful not to damage CV boot in the process!

Make sure that both puller lever arms are parallel to each other when using greatest force.

-- Separate the left and right guide link from the wheel bearing housing. Be careful not to damage the CV boot on the guide link joint pin.

-- Remove the threaded connector -1- for the right and left coupling rods on the shock absorber fork.

GWWA40-10387Courtesy of AUDI OF AMERICA, LLC

-- Disconnect and free up the connectors -1- for the Right Electrohydraulic Engine Mount Solenoid Valve -N145- and -2- and for the Left Electrohydraulic Engine Mount Solenoid Valve -N144-.

GWWA40-10548Courtesy of AUDI OF AMERICA, LLC

Applies to Audi RS 6 

GWWA10-11723Courtesy of AUDI OF AMERICA, LLC

-- Remove the nut -arrow-, free up the coolant pipe -1- and push it slightly to the side.

-- Remove the bolt -arrow- and free up the wiring harness.

GWWA10-11722Courtesy of AUDI OF AMERICA, LLC

Applies to Vehicles with a 6- or 8-Cylinder Engine 

GWWA10-11375Courtesy of AUDI OF AMERICA, LLC

-- Remove the bolts -arrows- and the left lower front longitudinal member -1-.

-- Remove the nuts and bolts -arrows- and free up the Ground (GND) cable -1- and the electric wire -2-.

GWWA40-10559Courtesy of AUDI OF AMERICA, LLC

-- Remove the right lower front longitudinal member.

-- Loosen the hose clamps -arrows-, then clamp off the coolant hoses with the :3094  and remove the hoses.

GWWA19-11527Courtesy of AUDI OF AMERICA, LLC

-- Disconnect the left and right connectors -1 and 2-.

GWWA10-11523Courtesy of AUDI OF AMERICA, LLC

-- Remove the connector -arrow- from the mount, disconnect it, and then guide it through the subframe.

GWWA10-11556Courtesy of AUDI OF AMERICA, LLC

Continuation for All 

GWWA10-11382Courtesy of AUDI OF AMERICA, LLC

-- Remove the nuts -1 and 2-, if necessary, and move the GND cable -arrow- to the side.

-- Remove the right and left clip -arrow- from the engine mount bracket and free up the wires and the metal bracket -1-.

GWWA40-10560Courtesy of AUDI OF AMERICA, LLC

-- Support the subframe using the :VAS6931  and a piece of hard wood, as shown.

GWWA10-10818Courtesy of AUDI OF AMERICA, LLC

-- Remove the bolt -arrow- for the left and right engine mounts.

GWWA40-10549Courtesy of AUDI OF AMERICA, LLC

-- Mark the location of the subframe to the longitudinal members using a felt-tip pen.

GWWA10-10868Courtesy of AUDI OF AMERICA, LLC

-- Remove the left and right bolts -1, 2 and 3- from the subframe diagonally and in steps.

-- Lower the subframe using the :VAS6931  .

NOTE:

Make sure there is enough clearance for the electric lines when lowering the subframe.