LEMON Manuals: Even more car manuals for everyone
Home >> Audi >> 2016 >> S5 Prestige, 2D Convertible >> Repair and Diagnosis >> External Pages >> Different car >> Section 79 (Engine Cooling System (H4DOTC)) >> Radiator >> Removal

Section 79 (Engine Cooling System (H4DOTC)): Radiator: Removal

WARNING: This page is about a different car, the 2012 Subaru Forester. However, it is still accessible from the selected car via links, so may be relevant.
CAUTION: The radiator is pressurized when the engine and radiator are hot. Wait until engine and radiator cool down before working on the radiator.
  1. Remove the collector cover.
  2. Disconnect the ground cable from battery.
    Fig 1: Disconnecting Ground Cable From Battery
    G07681015Courtesy of SUBARU OF AMERICA, INC.
  3. Lift up the vehicle.
  4. Remove the under cover. < Ref. to REMOVAL , Front Under Cover. >
  5. Remove the heat shield cover from radiator.
    Fig 2: Locating Radiator Heat Shield Cover Bolts
    G07681016Courtesy of SUBARU OF AMERICA, INC.
  6. Drain engine coolant. < Ref. to DRAINING OF ENGINE COOLANT , REPLACEMENT, Engine Coolant. >
  7. Disconnect the connector (A) from the main fan motor and the connector (B) from the sub fan motor.
    Fig 3: Main Fan Motor Connector
    G07681017Courtesy of SUBARU OF AMERICA, INC.
    Fig 4: Sub Fan Motor Connector
    G07681018Courtesy of SUBARU OF AMERICA, INC.
  8. Disconnect the radiator outlet hose from thermostat cover.
    Fig 5: Locating Radiator Outlet Hose Clamp
    G07681019Courtesy of SUBARU OF AMERICA, INC.
  9. Disconnect the ATF hoses from ATF pipes.
    NOTE: Plug the ATF pipe to prevent ATF from leaking.
    Fig 6: Locating ATF Hoses Clamps
    G07681020Courtesy of SUBARU OF AMERICA, INC.
  10. Lower the vehicle.
  11. Remove the air intake duct. < Ref. to REMOVAL , Air Intake Duct. >
  12. Remove the reservoir tank. < Ref. to REMOVAL , Reservoir Tank. >
  13. Disconnect the radiator inlet hose from the radiator.
    Fig 7: Locating Radiator Inlet Hose Clamp
    G07681021Courtesy of SUBARU OF AMERICA, INC.
  14. Disconnect the two engine coolant hoses from the radiator.
    Fig 8: Locating Engine Coolant Hoses Clamp
    G07681022Courtesy of SUBARU OF AMERICA, INC.
  15. Remove the radiator upper brackets.
    Fig 9: Locating Radiator Upper Brackets Bolts
    G07681023Courtesy of SUBARU OF AMERICA, INC.
  16. Move the radiator to the left while lifting it upward.
  17. Lift the radiator up and remove the radiator from vehicle.
  18. Remove the radiator lower cushion from the radiator lower bracket.
    Fig 10: Locating Radiator Lower Cushion
    G07681024Courtesy of SUBARU OF AMERICA, INC.