LEMON Manuals: Even more car manuals for everyone
Home >> Audi >> 2016 >> S5 Prestige, 2D Convertible >> Repair and Diagnosis >> External Pages >> Different car >> Section 79 (Engine Cooling System (H4DOTC)) >> Radiator Main Fan and Fan Motor >> Removal

Radiator Main Fan and Fan Motor: Removal

WARNING: This page is about a different car, the 2012 Subaru Forester. However, it is still accessible from the selected car via links, so may be relevant.
  1. Remove the collector cover.
  2. Disconnect the ground cable from battery.
    Fig 1: Disconnecting Ground Cable From Battery
    G07681037Courtesy of SUBARU OF AMERICA, INC.
  3. Lift up the vehicle.
  4. Remove the under cover. < Ref. to REMOVAL , Front Under Cover. >
  5. Disconnect the connector from the main fan motor.
    Fig 2: Locating Main Fan Motor Connector
    G07681038Courtesy of SUBARU OF AMERICA, INC.
  6. Remove the heat shield cover from radiator.
    Fig 3: Locating Radiator Heat Shield Cover Bolts
    G07681039Courtesy of SUBARU OF AMERICA, INC.
  7. Remove the ATF hose from the hose clip of the radiator main fan motor assembly.
    Fig 4: Locating ATF Hose Clip Of Radiator Main Fan Motor Assembly
    G07681040Courtesy of SUBARU OF AMERICA, INC.
  8. Lower the vehicle.
  9. Remove the air intake duct (Rear). < Ref. to REMOVAL , Air Intake Duct. >
  10. Remove the reservoir tank. < Ref. to REMOVAL , Reservoir Tank. >
  11. Remove the bolts which secure the radiator main fan motor assembly and the over flow pipe.
    Fig 5: Locating Bolts Which Secure Radiator Main Fan Motor Assembly And Over Flow Pipe
    G07681041Courtesy of SUBARU OF AMERICA, INC.
  12. Remove the radiator main fan motor assembly from the upper side of the vehicle.
scientia non olet · About LEMON Manuals