Brake Caliper, Replacing, Brake 1LV And 1ZK, Sq5: Removing

WARNING: This page does not describe the selected car, but rather 13 other vehicles, including the 2017 Audi SQ5, 2017 Audi Q5, 2016 Audi SQ5, 2016 Audi Q5, and 2015 Audi SQ5. However, it is still accessible from the selected car via links, so may be relevant.

Fig 1: Brake Pedal Depressor VAG 1869/2 Inserted Between Brake Pedal And Driver's Seat

Courtesy of AUDI OF AMERICA, LLC

-- Remove affected front wheel, refer to WHEEL, CHANGING AND MOUNTING .

-- Insert the Brake Pedal Actuator VAG1869/2 between the brake pedal and driver seat. Preload the brake pedal at least 60 mm.

NOTE:

By doing this, the valves in the brake master cylinder are closed and the brake fluid reservoir does not run empty.

Fig 2: Overview Of Front Brakes (1LV, 1ZK, And SQ5)

Courtesy of AUDI OF AMERICA, LLC

-- Connect the container hose to a front brake caliper bleed screw -2-.

-- Open a brake caliper bleed screw on the front brake caliper to reduce the pressure from the brake system.

WARNING:

Brake fluid is poisonous. NEVER siphon brake fluid with your mouth!
Wash off any brake fluid that comes into contact with the skin with a lot of water.
If brake fluid comes in contact with the eyes, wash out the eye(s) and see a doctor.
Refer to BRAKE FLUID GENERAL INFORMATION

-- Close the bleed screw.

NOTE:

Do not remove the Brake Pedal Actuator VAG1869/2.

-- Remove the brake hose -18- from brake caliper.

-- Remove the brake pads, refer to BRAKE PADS, REMOVING AND INSTALLING, BRAKE 1LV AND 1ZK, SQ5 .