LEMON Manuals: Even more car manuals for everyone
Home >> Acura >> 2009 >> TL Base >> Repair and Diagnosis >> Engine Mechanical >> Mechanical >> Cylinder Head (J35Z6) >> Valve Clearance Adjustment

Valve Clearance Adjustment

NOTE: Connect the Honda Diagnostic System (HDS) to the data link connector (DLC), and monitor the engine coolant temperature (ECT) sensor 1 Adjust the valve clearance only when the ECT sensor 1 temperature is less than 100°F (38°C)
  1. Remove the cylinder head covers (see TIMING BELT DRIVE PULLEY REPLACEMENT )
  2. Set the No 1 piston at top dead center (TDC) Align the pointer (A) on the front upper cover with the No 1 piston TDC mark (B) on the front camshaft pulley
    Fig 1: Aligning Pointer On Front Upper Cover
    G05986698Courtesy of AMERICAN HONDA MOTOR CO., INC.
  3. Select the correct feeler gauge for the valve clearance you are going to check

    Valve Clearance 

    Intake 0.20-0.24 mm (0.008-0.009 in) 

    Exhaust 0.28-0.32 mm (0.011-0.013 in) 

    REAR 

    Fig 2: Identifying Intake And Exhaust Valve Clearance - Rear
    G05986699Courtesy of AMERICAN HONDA MOTOR CO., INC.

    FRONT 

    Fig 3: Identifying Intake And Exhaust Valve Clearance - Front
    G05986700Courtesy of AMERICAN HONDA MOTOR CO., INC.
  4. Insert the feeler gauge (A) between the adjusting screw and the end of the valve stem on the No 1 cylinder, and slide it back and forth, you should feel a slight amount of drag

    INTAKE 

    Fig 4: Checking Intake Valve Clearance
    G05986701Courtesy of AMERICAN HONDA MOTOR CO., INC.

    EXHAUST 

    Fig 5: Checking Exhaust Valve Clearance
    G05986702Courtesy of AMERICAN HONDA MOTOR CO., INC.
  5. If you feel too much or too little drag, loosen the locknut, and turn the adjusting screw until the drag on the feeler gauge is correct

    INTAKE 

    Fig 6: Adjusting Intake Valve Screw
    G05986703Courtesy of AMERICAN HONDA MOTOR CO., INC.

    EXHAUST 

    Fig 7: Adjusting Exhaust Valve Screw
    G05986704Courtesy of AMERICAN HONDA MOTOR CO., INC.
  6. While holding the adjusting screw with the screw driver, tighten the locknut, then recheck the clearance Repeat the adjustment, if necessary

    Specified Torque 

    Intake 20 N m (2 0 kgf m, 14 lbf ft) 

    Apply new engine oil to the nut threads 

    Exhaust 14 N m (1 4 kgf m, 10 lbf ft) 

    Apply new engine oil to the nut threads 

  7. Rotate the crankshaft clockwise Align the pointer (A) on the front upper cover with the No 4 piston TDC mark (B) on the front camshaft pulley
    Fig 8: Identifying Pointer On Front Upper Cover With No 4 Piston TDC Mark On Front Camshaft Pulley
    G05986705Courtesy of AMERICAN HONDA MOTOR CO., INC.
  8. Check and, if necessary, adjust the valve clearance on the No 4 cylinder
  9. Rotate the crankshaft clockwise Align the pointer (A) on the front upper cover with the No 2 piston TDC mark (B) on the front camshaft pulley
    Fig 9: Identifying Pointer On Front Upper Cover With No 2 Piston TDC Mark On Front Camshaft Pulley
    G05986706Courtesy of AMERICAN HONDA MOTOR CO., INC.
  10. Check and, if necessary, adjust the valve clearance on the No 2 cylinder
  11. Rotate the crankshaft clockwise Align the pointer (A) on the front upper cover with the No 5 piston TDC mark (B) on the front camshaft pulley
    Fig 10: Identifying Pointer On Front Upper Cover With No 5 Piston TDC Mark On Front Camshaft Pulley
    G05986707Courtesy of AMERICAN HONDA MOTOR CO., INC.
  12. Check and, if necessary, adjust the valve clearance on the No 5 cylinder
  13. Rotate the crankshaft clockwise Align the pointer (A) on the front upper cover with the No 3 piston TDC mark (B) on the front camshaft pulley
    Fig 11: Identifying Pointer On Front Upper Cover With No 3 Piston TDC Mark On Front Camshaft Pulley
    G05986708Courtesy of AMERICAN HONDA MOTOR CO., INC.
  14. Check and, if necessary, adjust the valve clearance on the No 3 cylinder
  15. Rotate the crankshaft clockwise Align the pointer (A) on the front upper cover with the No 6 piston TDC mark (B) on the front camshaft pulley
    Fig 12: Identifying Pointer On Front Upper Cover With No 6 Piston TDC Mark On Front Camshaft Pulley
    G05986709Courtesy of AMERICAN HONDA MOTOR CO., INC.
  16. Check and, if necessary, adjust the valve clearance on the No 6 cylinder
  17. Install the cylinder head covers (see CYLINDER HEAD COVER INSTALLATION )