Inflatable Curtain [2018-2022]: Removal

NOTE:

Removal steps in this procedure may contain installation details.

Follow instructions about safety information pyrotechnical system. Refer to: SAFETY INFORMATION PYROTECHNICAL SYSTEMS

See information regarding the handling of non-deployed pyrotechnical parts. Refer to: HANDLING NON-DEPLOYED PYROTECHNICAL PART

Remove the following items:

A-pillar trim panel. Refer to: A-PILLAR TRIM PANEL
C-pillar trim panel. Refer to: C-PILLAR TRIM PANEL
inner rear view mirror. Refer to: INNER REAR VIEW MIRROR

GLL1026830

Courtesy of VOLVO CARS CORPORATION

NOTE:

The graphic shows the back of the component before removal.

GLL1004411

Courtesy of VOLVO CARS CORPORATION

Loosen the marked detail.

On both sides.

GLL1012939

Courtesy of VOLVO CARS CORPORATION

Fold marked part aside.

On both sides.

GLL1000124

Courtesy of VOLVO CARS CORPORATION

Torque: Entry handle, to bracket, 6Nm

Remove the screws.

On both sides.

GLL1000528

Courtesy of VOLVO CARS CORPORATION

NOTE:

The graphic shows the back of the component before removal.

GLL1022312

Courtesy of VOLVO CARS CORPORATION

Remove the marked detail/details.

On both sides.

GLL1000724

Courtesy of VOLVO CARS CORPORATION

Torque: M6, 10Nm

Remove the screw.

Remove the cable harness clips.

GLL1025964

Courtesy of VOLVO CARS CORPORATION

Remove the cable harness clips.

ON BOTH SIDES.

GLL1022289

Courtesy of VOLVO CARS CORPORATION

GLL1000515

Courtesy of VOLVO CARS CORPORATION

GLL1015858

Courtesy of VOLVO CARS CORPORATION

Release the lock.

GLL1028707

Courtesy of VOLVO CARS CORPORATION

Remove the marked part.

GLL1025896

Courtesy of VOLVO CARS CORPORATION

NOTE:

The graphic shows the back of the component before removal.

GLL1000172

Courtesy of VOLVO CARS CORPORATION

Remove the marked part.

GLL1017177

Courtesy of VOLVO CARS CORPORATION

Remove the screws.

GLL1021284

Courtesy of VOLVO CARS CORPORATION

Fold marked part aside.

GLL1011577

Courtesy of VOLVO CARS CORPORATION

Fold marked part aside.

GLL1038009

Courtesy of VOLVO CARS CORPORATION

Loosen the screws.

VEHICLES WITH ROOF OPENING PANEL

GLL1037658

Courtesy of VOLVO CARS CORPORATION

Disconnect the connector.

GLL1023404

Courtesy of VOLVO CARS CORPORATION

CAUTION:

Take extra care not to crease the headliner.

NOTE:

Velcro strip

Use: Interior trim remover

VEHICLES WITHOUT ROOF OPENING PANEL

GLL1013094

Courtesy of VOLVO CARS CORPORATION

CAUTION:

Take extra care not to crease the headliner.

NOTE:

Velcro strip

Use: Interior trim remover

ALL VEHICLES

GLL1030350

Courtesy of VOLVO CARS CORPORATION

Lower to suitable height.

Perform battery disconnecting and connecting. Refer to: BATTERY DISCONNECTING AND CONNECTING

WARNING:

The supplemental restraint system (SRS) is active for a certain length of time after the power supply has been disconnected. Wait for a minimum of 30 seconds before disconnecting or removing any SRS components.

GLL1012159

Courtesy of VOLVO CARS CORPORATION

Torque: Entry handle bracket, to Body, 7Nm

Remove the screws.

Remove the marked part.

Dismantle the connector ignition cable. Refer to: IGNITER WIRE CONNECTOR

GLL1032494

Courtesy of VOLVO CARS CORPORATION

Disconnect the connector.

GLL1011502

Courtesy of VOLVO CARS CORPORATION

Remove the screw.

Release the catches.

GLL1000462

Courtesy of VOLVO CARS CORPORATION

Remove the screws.

GLL1010063

Courtesy of VOLVO CARS CORPORATION

Remove the screws.

GLL1019779

Courtesy of VOLVO CARS CORPORATION

Remove the marked part.

GLL1024181

Courtesy of VOLVO CARS CORPORATION

Remove the marked part.