Checking Wiring For Lock Motor

Check the cable between central electronic module (CEM) terminal #C5 (#5) and the lock motor, fuel tank filler cover terminal #A2. Check for an open circuit or shorting to ground.

Check the cable between the lock motor, fuel tank filler cover terminal #A1 and ground. Check for an open-circuit or short-circuit to supply voltage.

Remedy wiring as necessary.

If no other fault is discovered, replace the lock motor for the fuel tank filler cover.

Other information 

• see CONNECTING THE BREAKOUT BOX (2004, 2005, 2006, 2007)
• see SIGNAL DESCRIPTION CENTRAL ELECTRONIC MODULE (CEM) (2004, 2005, 2006, 2007)
• see CONTROL MODULE RELAY BOX PASSENGER COMPARTMENT
• see DOOR LATCH FUEL FILLER DOOR

Fig 2: Identifying Connector Terminals

Courtesy of VOLVO CARS OF NORTH AMERICA.

Fig 3: Identifying Ohmmeter

Courtesy of VOLVO CARS OF NORTH AMERICA.

Refer to VERIFICATION